Suzuki Intruder 1978 - Page 78

}
Engine Problem (Continued)
Engine stops (suddenly) after
running.
Engine stops
(gradually) after
running .
Drive Converter Problem
Drive converter engages be-
fore specified RPM .
Drive converter engages after
specified RPM.
Condition
1. Defective ignition coil.
2. Obstruction in fuel tank or
fuel filter .
3. Fuel line obstructed or
pinched.
4. Defective CDI i gniter .
5. Spark plug bridged.
6. Seized piston(s).
7. Seized cra nkshaft.
8. Defective exciter coil.
9. Defective pulser coil.
1. Obstruction in fuel tank or
fuel filter.
2. Fuel line obstructed or
pinched.
3. Damaged head gasket(s).
4. Loose cylinder head.
5. Loose spark plug(s).
Condition
1.
Incorrect spring.
2.
Weak or da maged spring.
3. Incorrect weights.
1 . Incorrect spring.
2. Incorrect weights.
3. Dirty movable sheave.
Remedy
1. Replace ignition coil.
2. Clean or replace filter.
3. Remove obstruction, re -
move pinched area from
fuel
line.
4. Replace COl igniter.
5. Replace spark plug.
6. Replace piston and any af-
fected components.
7. Replace crankshaft and any
affected
components .
8. Replace exciter coil.
9. Replace pulser coil.
1. Clean or replace filter.
2. Remove obstruction , re-
move pinched area from
fuel
line.
3. Replace head gasket(s).
4. Tighten cylinder head nuts
to correct torque.
5. Tighten spark plug(s) to
correct
torque .
Remedy
1. Install
correct spring.
2.
Replace spring.
3. Install correct weights .
1 . Install
correct spring.
2. Install correct weights .
3.
Clean movable sheave.
4. Worn (flat spots) rollers and 4. Replace rollers and ramps.
ramps.
5. Bushing in housing worn
excessively on inside diame-
ter.
5. Replace components as re-
quired.
TROUBLESHOOTING 3 -5