Home
Trane
Air Conditioner
YSC072F
Trane YSC072F User Manual
5
of 1
of 1 rating
72 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Installation
38
RT
-SVX21P
-EN
Figur
e
44.
ReliaT
el™
humidistat
(dehumidification
option)
Figur
e
45.
Electr
omec
hanical
contr
ol
customer
low
voltag
e
routing
(all
units
except
1
0
ton
high
efficiency)
Figur
e
46.
ReliaT
el™
control
customer
low
v
oltage
routing
(all
units
except
1
0
ton
high
efficiency)
37
39
Table of Contents
Introduction
2
Warnings, Cautions, and Notices
2
Important Environmental Concerns
2
Important Responsible Refrigerant Practices
2
Copyright
3
Table of Contents
4
Model Number Description
6
Model Number Notes
7
Model Number Description - 17 Plus
8
Model Number Notes
9
General Information
10
Unit Inspection
10
Storage
10
Unit Nameplate
10
Compressor Nameplate
10
Microchannel Condenser Barcode ID
10
Unit Description
10
Economizer Control Actuator (Optional)
10
System Input Devices & Functions
11
Low Pressure Control
12
High Pressure Control
12
Power Exhaust Control (Optional)
12
Lead/Lag Control (Dual Circuit Only)
12
Evaporator Frost Control
13
Discharge Line Temp Switch (DLTS)
14
Smoke Detector Sensor (Optional)
14
Phase Monitor
14
Single Zone Variable Air Volume / Displacement Ventilation (Optional)
14
Human Interface - 5 Inch Color Touchscreen (Optional)
14
Unit Dimensions
15
Installation
22
Pre-Installation
22
Procedure
22
Foundation
24
Horizontal Units
24
Ductwork
25
Roof Curb
26
Downflow
26
Rigging
27
General Unit Requirements
27
Factory Installed Economizer
28
Temperature Limit Switch Usage for Gas Heat Units
28
Horizontal Discharge Conversion
29
Units)
29
TCO-1 Instructions
29
Horizontal Discharge Conversion
30
Units)
30
TCO1 Instructions
31
Return Air Smoke Detector
31
Main Electrical Power Requirements
32
Through-The-Base Gas Installation
33
Requirements for Gas Heat
33
Condensate Drain Configuration
33
Filter Installation
34
Field Installed Power Wiring
34
Main Unit Power
35
Standard Wiring
35
Optional TBUE Wiring (Through-The-Base Electrical Option)
35
Field-Installed Control Wiring
36
Control Power Transformer
36
Controls Using 24 VAC
36
Controls Using DC Analog Input/Outputs (Standard Low Voltage Multi Conductor Wire)
36
DC Conductors
37
Space Temperature Averaging
41
Pre-Start
44
Voltage Imbalance
44
Electrical Phasing (Three Phase Motors)
44
Compressor Crankcase Heaters (Optional)
45
Reliatel™ Controls
45
Test Modes
46
Reliatel™ Controls
46
Electromechanical Controls Test Procedure
47
Unit Start-Up
48
Verifying Proper Air Flow
48
Units with 5-Tap Direct Drive Indoor Fan
48
Units with Belt Drive Indoor Fan
48
Units with Direct Drive Indoor Fan - Electromechanical Control
49
Reliatel™ Units with Direct Drive Indoor Fan (7½ - 8½ Ton High Efficiency, 10 Ton Standard Efficiency)
49
Fan
49
Plus Units with the Constant CFM Direct Drive Indoor Fan
50
Vhr Relay Output
51
Variable Air Volume Applications
51
Vav)
51
Supply Duct Static Pressure Control
52
Traditional VAV Standalone Operation
52
Supply Air Temperature Reset
52
Return Air Smoke Detector
53
Economizer Start-Up
53
Compressor Start-Up
54
Dehumidification Option
54
Gas Heat Units
54
Final System Setup
55
Maintenance
56
Fan Belt Adjustment - Belt Drive Units
56
Monthly Maintenance
57
Filters
57
Return Air Smoke Detector Maintenance
57
Condensate Overflow Switch
57
Cooling Season
57
Heating Season
57
Coil Cleaning
58
Annual Maintenance
59
Troubleshooting
60
Reliatel™ Control
60
System Status Checkout Procedure
60
Method 1
60
Service Failure
61
Simultaneous Heat and Cool Failure
61
System Failure
61
Cooling Failure
61
Resetting Cooling and Ignition Lockouts
62
Zone Temperature Sensor (ZTS) Service Indi
62
Cator
62
Clogged Filter Switch
62
Fan Failure Switch
62
Condensate Overflow Switch
62
Zone Temperature Sensor (ZTS) Tests
62
Test 1 - Zone Temperature Thermistor (ZTEMP)
62
Test 2 - Cooling Set Point (CSP) and Heating Set Point (HSP)
62
Test 3 - System Mode and Fan Selection
62
Test 4 - LED Indicator Test
63
Cool & Service)
63
Relative Humidity Sensor Test
63
Programmable & Digital Zone Sensor Test
63
Reliatel™ Refrigeration Module (RTRM) Default Chart
63
Unit Operation Without a Zone Sensor
63
Unit Economizer Control (ECA) Troubleshoot
64
Ing
64
Reliatel™ Control
64
Electromechanical Control
64
Unit Economizer Control (ECA) Test Proce
66
Dures
66
Electromechanical Control
66
Troubleshooting Procedures for Direct Drive
66
Plenum Fan
66
Unit Wiring Diagrams Numbers
67
Limited Warranty
69
Combination Gas Electric Air Conditioner
69
YCC, YCD, YCH, YCP , YSC and YHC (Parts Only)
69
Models Less than 20 Tons for Residential Use
69
Ycz, Ycy, Ycx, Ycc, Ycd, Ych, Ycp, Yhc
69
And YSC (Parts Only)
69
Models Less than 20 Tons for Commercial Use
69
Other manuals for Trane YSC072F
Owner's Manual
2 pages
Installation, Operation And Maintenance
68 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Trane YSC072F and is the answer not in the manual?
Ask a question
Trane YSC072F Specifications
General
Brand
Trane
Model
YSC072F
Category
Air Conditioner
Language
English
Related product manuals
Trane YSC072H
84 pages
Trane YSC037E
72 pages
Trane YSC036E
72 pages
Trane YSC060E
72 pages
Trane YSC060G
84 pages
Trane YSC120
48 pages
Trane YSC120F
72 pages
Trane YSC120ED
48 pages
Trane YSJ072A
64 pages
Trane Precedent YSJ072
76 pages
Trane Voyager YS 150–300
52 pages
Trane YHC036E
84 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
