Universal M-35B(C) User Manual

CAPTAIN CONTROL PANEL
DESCRIPTION
This manually-operated control panel is equipped with a
KEY switch, an RPM gauge, PREHEAT and START but-
tons, an INSTRUMENT TEST button and three indicator
lamps,
one for AL1ERNATOR DISCHARGE, one for low
OIL PRESSURE, and one for high ENGINE COOLANT
TEMPERATURE.
RPM GAUGE: REGISTERS REVOLUTIONS
PER MINUTE OFTHE ENGINE AND CAN BE
RECALIBRATED FOR ACCURACY FROM
THE REAR OF THE PANEL.
START BUTTON: WHEN PRESSED, ENERGIZES THE
STARTER'S SOLENOID WHICH CRANKS THE ENGINE. THIS
BUTTON WILL NOT OPERATE ELECTRICALLY UNLESS THE
PREHEAT BUTTON IS PRESSED AND HELD AT THE SAME
TIME.
The panel also includes an alarm buzzer for low on.
PRESSURE or high COOLANT TEMPERATURE. The
RPM gauge is illuminated when the KEY switch is turned on
and remains illmninated while the engine is in operation.
ALARM: THE ALARM WILL SOUND IF THE ENGINE'S OIL PRESSURE FALLS
BELOW 10- 5 psi (0.7 - 0.4 kg/em"). IN THIS EVENT, THE ALARM WILL EMIT A
PULSATING SIGNAL THE ALARM WILL ALSO SOUND IF THE COOLANT
TEMPERATURE IN THE FRESHWATER. COOLING CIRCUIT RISES TO
210"F (99"C). IN THIS EVENT, THE ALARM WILL EMIT A CONTINUOUS SIGNAL.
NOTE: THE ALARM WILL SOUND WHEN THE KEY SWITCH IS TURNED ON. THIS
SOUNDING IS NORMAL ONCE THE ENGINE STARTS AND THE ENGINE'S OIL
PRESSURE REACHES 15 psi (1.1 kg/em"), THE ALARM WILL SILENCE.
TEST BunDN: WHEN
PRESSED, TESTS THE
ALTERNATOR, THE OIL
PRESSURE, AND THE
COOLANT TEMPERA-
TURE CONTROL CIR-
CUITS. WHEN PRESSED,
THE ALTERNATOR, THE
OIL PRESSURE, AND
THE WATER TEMPERA-
TURE INDICATOR
LIGHTS ILLUMINATE IN
ADDITION TO SOUND-
ING THE ALARM
BUZZER..
~-----~~swrr~:THEKEY
SWITCH WHEN TURNED ON
SUPPLIES DC POWER TO THE
INSTRUMENT PANEL
CWSTER, PREHEAT SWITCH,
EXCITATION TERMINAL OF THE
DC CHARGING ALTERNATOR
AND TO THE ALARM BUZZER
ENERGIZING IT IN A PULSING
MODE.
BUTTON: WHEN DEPRESSED, IT CLOSES
THE CONTACTS IN THE PREHEAT SOLENOID SENDING
POWER TO THE GLOW PLUGS. THE "I" TERMINAL ON THE
PREHEAT SOLENOID ALSO RECEIVES POWER AND THIS IS
TRANSMITTED TO THE ELECTRIC FUEL PUMP. DC POWER
IS ALSO TRANSMITTED TO THE START BUTTON.
4 4
Unlvarsal
£ 6 mN;!I§Ij#•M!;M
6

Universal M-35B(C) Specifications

General

Brand	Universal
Model	M-35B(C)
Category	Engine
Language	English