Upright ab62 User Manual

104044-001 AB62 Work Platform - Operator Manual Page 1
O
PERATOR
M
ANUAL
WARNING
All personnel shall carefully read, understand and follow all safety rules and operating instructions
before operating or performing maintenance on any UpRight aerial work platform.
Safety Rules
Safety RulesSafety Rules
Safety Rules
•
ALL OCCUPANTS
must wear an approved fall restraint properly attached to a designated anchorage point. Attach only
one fall restraint to each anchorage point.
•
NEVER
exceed the maximum platform load. See “Specifications” on page 20.
•
NEVER
operate the machine without first surveying the work area for surface hazards such as holes, drop-offs, bumps,
curbs, or debris.
•
ALWAYS
close and secure entrance after entering the platform.
•
NEVER
use ladders or scaffolding on the platform.
•
NEVER
attach overhanging loads or use the aerial work platform as a crane or lifting tool.
•
LOOK
up, down and around for overhead obstructions and electrical conductors.
•
DISTRIBUTE
all platform loads evenly on the platform.
•
NEVER
use damaged equipment. (Contact UpRight for instructions. See toll free phone number on inside back cover.)
•
NEVER
change operating or safety systems.
•
INSPECT
the machine thoroughly for cracked welds, loose or missing hardware, hydraulic leaks, damaged cables or
hoses, loose wire connections, and wheel bolts.
•
NEVER
climb down the elevating assembly when the platform is elevated.
•
IF ALARM SOUNDS
while the platform is elevated, STOP, carefully lower the platform. Move the machine to a firm, level
surface.
•
IN CASE OF EMERGENCY
push the Emergency Stop button to cut power to all machine functions.
•
NEVER
recharge batteries near sparks or open flame; batteries that are being charged emit explosive hydrogen gas.
•
NEVER
replace any component or part with anything other than original UpRight replacement parts without the manufac-
turer’s written consent.
•
VERIFY
that all labels are in place and legible before using.
•
NEVER
tow the machine. Transport by truck or trailer only.
•
AFTER USE
, secure the work platform against unauthorized use by turning key switches off and removing all keys.
California Proposition 65 Warning
Gasoline and diesel engine exhaust and some of their constituents are known to the State of California to
cause cancer, birth defects, and other reproductive harm.
Battery Posts, terminals and related accessories contain lead compounds, chemicals known to the State of
California to cause cancer and reproductive harm. Wash hands after handling.
NEVER operate the boom or drive with
the platform elevated unless on firm,
level surface.
NEVER position the platform without
first checking for overhead obstructions
or other hazards.
NEVER climb, stand or sit on the
platform guardrails or midrail.
Electrocution Hazard
Electrocution HazardElectrocution Hazard
Electrocution Hazard Tip Over Hazard
Tip Over HazardTip Over Hazard
Tip Over Hazard Collision Hazard
Collision HazardCollision Hazard
Collision Hazard Fall Hazard
Fall HazardFall Hazard
Fall Hazard
NEVER operate the machine within ten
(10) feet of power lines.
THIS MACHINE IS NOT INSULATED.

Upright ab62 Specifications

General

Brand	Upright
Model	ab62
Category	Lifting Systems
Language	English