VER-MAC PCMS Series

To Previous Page

Appendix C – Setup and Takedown for a Telescopic Camera Give us your thoughts

56 PCMS Operations, Safety & Maintenance V3.0 Ver-Mac 2018

PART №:

Sticker

E-8152

Location: Inside the controller box, on door.

E-8153

Location: Inside the controller box, on door.

Main Page

Table of Contents6
Overview9
About Your Portable Changeable Message Sign Model9
Safety and Warning Information9
Maintenance10
Troubleshooting11
About Replacement Parts11
About Maximum Speeds11
Pre-Towing and Work Site Inspections12
Walk-Around Inspection of PCMS Unit12
Work Site Inspection (before PCMS Unit Setup)14
Unit Deployment and Removal15
Trailer Deployment15
Setup and Adjustment of Signboard and Solar Array16
Ballast16
Messages16
Takedown of Signboard and Solar Array17
Trailer Removal17
Trailer Maintenance18
Safety and Instructions Stickers18
Pre-Maintenance Procedure18
Trailer Structure19
Jacks19
Trailer Lights and Reflectors20
PCMS Unit Hardware and Fasteners21
Tires and Rims22
Trailer Tire Wear Diagnostic Chart22
Replacement Tires and Rims23
Lug Nuts on Wheel23
Tire and Rim Periodic Maintenance24
Axles and Suspension25
Axle Periodic Maintenance25
Brakes and Breakaway Systems26
Electric Brakes26
Hydraulic Surge Brakes27
Manual Brake on the Trailer29
No Independent Trailer Braking System29
Breakaway System30
Safety Chains31
Brakes and Breakaway System Periodic Maintenance32
Coupler/Hitch33
Pintle Hook and Lunette Ring Combination33
Ball Coupler/Hitch33
Coupler/Hitch Periodic Maintenance34
Mast Maintenance35
Mast Periodic Maintenance35
Hydraulic Lift System for Mast35
Reversible Hand Winch System for Mast36
Signboard39
Sign Brake39
Photocells39
Radar Device40
Sign Display40
Signboard Exterior Periodic Maintenance40
Signboard Interior Periodic Maintenance42
Solar Array43
Solar Panels43
Orientation and Tilt43
Care and Cleaning of Solar Panels44
Replacement Solar Panels44
Solar Array Periodic Maintenance44
Battery Bank46
First Aid Procedures47
Deep-Cycle Battery Maintenance48
Sealed Battery Maintenance51
Suggested Recharging Times51
Charging with an External Charger52
Charging the Batteries with the Onboard Charger53
Replacement Batteries53
Battery Bank Periodic Maintenance54
Controller Cabinet55
Solar Regulator55
Controller Cabinet Periodic Maintenance57
Appendix A - Full Brake Maintenance58
Full Brake Maintenance (Hydraulic and Electric Systems)58
Appendix B - Safety Warning and Instructions Stickers59
Appendix C - Setup and Takedown for a Telescopic Camera61
Trailer Deployment61
Solar Panels and Camera Setup61
Sign Case Setup61
Sign Case Takedown62
Solar Panels and Camera Takedown62
Positioning Unit for Transport62
Safety Stickers for the Camera Option63

VER-MAC PCMS Series - Page 64

Table of Contents

Related product manuals