- 41 -
Drain condensate and water from spillage-free frame (8) x x
Check for leaks in engine-air-, oil-, or fuel system (8) x x
Inspect/Replace hoses and clamps xx
Check electrical system cables for wear xx
Check/Test glow plugs xx
Check torque on critical bolt connections (12) x x
Check electrolyte (if applicable) battery terminals (10) x x
Grease locks and hinges xx
Check rubber flexibles (9) xx
Drain/Clean fuel tank water and sediment (1) (14) x
Replace fuel tank breather filter xx
Adjust engine inlet and outlet valves (2) x
Check engine protective devices (15) xx
Inspect starter motor xx
Inspect charging alternator xx
Alternator
Measure alternator diodes xx
Measure alternator windings insulation resistance (11) xx
Test Earth Leakage breaker (13) xx
Check alternator and cubicle electrical system and cables for wear xx
Check alternator cable connections on terminals (12) xx
Maintenance schedule
Daily
50 hours after initial
start-up
Every 500 hours Every 1000 hours Yearly
Service pack
- - 1636 3104 13 - -
00_00_HiLight H5+-H2_EN.book Page 41 Thursday, February 27, 2020 3:23 PM
To Next Page
Loading...
