Allgemeines.pm6.5 - USA
Page 1.2
General
BOGE Operating instructions for S 40-2...S 341 / SF 40-2...SF 220 series screw compressors
1. Ensure that maintenance work is only carried out by appropriately trained
persons.
2. Ensure that setting work, malfunction rectification and repair are only
carried out by specialists or appropriately trained persons.
3. Prior to maintenance or repair work:
– Switch off main switch.
– Secure main switch against unintentional switch-on.
– Check to ensure that all parts have been isolated.
– Disconnect compressor from compressed air network (relieve or block
pressurized lines).
4. Exercise extreme caution during repair or maintenance work requiring
compressor to be operational.
Ensure that no persons are located in the hazardous area.
5. Ensure that work on the electrical equipment is only undertaken by quali-
fied electricians.
6. Work on voltage carrying parts and devices are not permitted. Exceptions
are governed by the appropriate regulations.
CAUTION
7. Only use original spare parts, compressor oils and operating
materials released by BOGE during repair or maintenance.
8. The operator is required to check the compressor daily for externally vis-
ible damage and defects, and to immediately report any changes (includ-
ing operational behavior).
9. When the automatic restart (Auto-Restart) is activated, the compressor
restarts automatically following a voltage loss.
Prerequisite: The net pressure is lower than the switch-on pressure.
The owner of a compressor plant is required to ensure that it is properly in-
stalled, operated and maintained.
For operation of the compressor plant, the accident prevention regulations
of the owner country must be observed in addition to the data contained in
these operating instructions.
In the event that measures are required above and beyond the legal regu-
lations or the data contained in these operating instructions, then it is of
utmost importance that these be carried out prior to commissioning the
compressor plant.
Accident prevention
regulations
Safety instructions for
maintenance and repair
of the compressor
1.1 General safety instructions
To Next Page
Loading...
Need help?
General
