Buhnen HB 710 - Safety Instructions; Potential Hazards; Instructions for Safe Operation

3
2 Safety instructions
2.1 Potential hazards
Danger!
Neverpointtheoperation-readydeviceatpeople.
Dangerfromhighpressure!
Burn Hazard
Nozzle(1)andmoltenadhesivecanbeover390°F/200°Chot.
Wearheat-resistantglovesifcontactisunavoidable.
Risk of Explosion!
Whenworkingwithoxygenorcombustiblegasesthereisriskofexplosion!
Xi
Odor nuisance!
Hot-meltadhesivesgiveofffumeswhichcancauseodournuisance–soensure
adequateventilation.
Improperusemayinisolatedcasesleadtoirritationofthemucousmembrane.Inthis
caseseekimmediatemedicaladvice!
2.2 Instructions for safe operation
Guardagainstmalfunctionsandoperatingerrorsbyalwaysfollowingtheseinstructions
precisely:
• Innocircumstancesmaythemaximumpermittedoperatingpressure(87psi/6bar)be
exceeded.
• Removecombustibleorheat-sensitiveobjectsfromtheareaofthenozzle(1).
• Whenwarmthedevicemustbeputdownonthesupporthoop(18)orworkingconsole.
Itmustnotbelaidonitsside.
Otherwisemeltmayescapeuncontrolledthroughtheventholesandpresentaburn
hazard.
• Neveroperatethetrigger(16)forcibly.
• Protectthedevicefrommoistureanddamp(protectionagainstelectricshock).
• Observetheinstructionleaetforthehot-meltadhesive(protectionagainstprocessing
errors).
• Operatethedeviceonlywiththenozzlepointingdownwards.Itmustnotbeoperated
aboveheadheight!
• Unplugfromthemainsbeforeperforminganyoperationonthedevice(servicing,clean-
ing).
• Thedevicemustbepoweredonlyfromsocketswithaprotectiveconductor.
• Anyextensioncableusedmusthaveaprotectiveconductor.Checkthattheprotective
conductorisundamagedbeforeuse.
• Unplug
fromthemainsaftereachuse.Allowthedevicetocooldowncompletelybefore
puttingitaway.
• Ifyounoticeanydamagetothedeviceorleads,unplugfromthemainsimmediately.
Havethedevicepromptlycheckedoverbyanexpert.Itmustnotbeusedagainuntilit
hasbeenproperlyrepaired(seeSections6and7).
Safety instructions