Chamberlain MT5011U - Carton Inventory and Preparation; Carton Inventory Checklist; Door Preparation Steps

5
PREPARATION
PREPARING YOUR DOOR
The manufacturer recommends 3 feet (91.4 cm) of clearance around the operator for serviceability. Before you begin:
• Disable locks.
• Remove any ropes connected to door.
• Before the operator is installed, be sure the door has been properly aligned and is working smoothly. Although each installation will
vary due to particular building characteristics, refer to the following general procedures to install the operator.
Before beginning your installation check that all components were provided.
CARTON INVENTORY
M
M
O
O
D
D
E
E
L
L
M
M
T
T
5
5
0
0
1
1
1
1
U
U
/
/
B
B
M
M
T
T
5
5
0
0
1
1
1
1
U
U
QUICK START
aglkdngdna diakdn
alkndjandjan
adlknsa;fkn;d
agndan;djksna;dkjn
dgajndsandoai
langdlaknskdnoa
lknagdndjoang;
gksdjna;ogdnr
aglkna;gn;djkand
adgsndajgndoia
lajgdajngciosuhadoajdna ld
dagjdl;abndjnbag;duhajbdnkajbn
agjdaghadsuabndkjbn
dsgakjbndsubhadsjbnakjdbn
kgjadkjbagudb
kdsjgbsAZdlsuabhdijbadub
^
^
OPENOPEN
CLOSECL
OSE
O
STOPST
OP
NOTE: The tracks are shipped separately. Actual track length will exceed door height by 2 feet. EXAMPLE: The track for 12 foot door will
be 14 feet.
M
M
O
O
D
D
E
E
L
L
M
M
T
T
5
5
0
0
1
1
1
1
U
U
/
/
B
B
M
M
T
T
5
5
0
0
1
1
1
1
U
U
QUICK START
aglkdngdna diakdn
alkndjandjan
adlknsa;fkn;d
agndan;djksna;dkjn
dgajndsandoai
langdlaknskdnoa
lknagdndjoang;
gksdjna;ogdnr
aglkna;gn;djkand
adgsndajgndoia
lajgdajngciosuhadoajdna ld
dagjdl;abndjnbag;duhajbdnkajbn
agjdaghadsuabndkjbn
dsgakjbndsubhadsjbnakjdbn
kgjadkjbagudb
kdsjgbsAZdlsuabhdijbadub
^
^
OPEN
CL
OSE
O
ST
OP
NOT SHOWN
Installation Manual
Quickstart Guide
User’s Guide
Entrapment Warning Placard
Installation Hardware Bag, Complete with: Bolts 3/8"-16 x 3/4" (10), Flanged Hex Nuts 3/8"-16 (14), Bolt 3/8"-16 x 1 (3),
Lock Washers 3/8" (3), Cotter Pins (2) and Carriage Bolts (2)
NOTE: Depending on door height, the quantity of track spacers and hardware may vary.
Operator
Track (left and right) door
height plus 2 feet (2)
Track Spacers (2)
Front Idler
Trolley
Take-up Bolt
Chain
Master Links (2)
Warning Placard
3-Button Station
Header Bracket
Header Pivot Shaft
Curved Door Arm
Straight Door Arm
Door Bracket