Chery A11 2003 User Manual

CAC Gasoline Engine Maintenance And Servicing Manual
71
Carburetor engine faults ,causes and corrections
1.engine does not run during starting:
Cause
correction
(1). Battery wires are loose or corroded reconnect or replace the
wires .
(2). Battery is discharged or damaged recharge or replace the
battery .
(3). Starter circuits is opened or loosed or not energized energize or replace the harness
(4). Starter solenoid valve or switch is damaged replace starter solenoid valve or
switch
(5). Starter is damaged replace starter
(6). Flywheel gear ring or starter pinion is loosed or damaged replace flywheel gear ring or
starter
(7). No engine ground wire or ground wire is disconnected connect or replace the ground
wire
2. engine runs but no spark exists during starting:
Cause
correction
(1). No fuel in fuel tank fuel the tank
(2). No fuel in the carburetor float chamber keep trying to start
engine
(3). Battery is discharged(engine run slowly) recharge or replace battery
(4). Battery wire connector is loosed or corroded reconnects or replace battery
(5). Ignition parts is damp or damaged replace ignition parts
(6). Ignition part harness is opened ,loosed or not energized. Reconnect or replace harness
(7). Spark plug is burned away, damaged or
Spark plug gap is not correct. Replace spark plug
(8). Main mechanism is damaged(for example, camshaft) check and service
(9). Fuel pump is damaged replace pump
(10).Carburetor float chamber needle valve is binding or
oil strainer is blocked check, service and clean
(11).Idle cut-off valve does not open check circuit and solenoid
3. difficult to start for engine when temperature is low:
Cause correction
(1). Battery discharged recharge battery
(2). Battery connector loosed or corroded connect or replace the battery wires.
(3). Spark plug is corroded , damaged or the
Spark plug gap is not right. Replace spark plug
(4). Other ignition system problem s check and service
(5). Low cylinder compression pressure sent to service spot for check and service
PDF 文件使用 "pdfFactory Pro" 试用版本创建 www.fineprint.com.cn

Chery A11 2003 Specifications

General

Brand	Chery
Model	A11 2003
Category	Automobile
Language	English