DG Flugzeugbau LS4 - Page 115

Maintenance Manual LS4
Issued: May 2011
Copyright DG Flugzeugbau GmbH - any copy or publishing prohibited
Manual valid with the up-to-date cover page only
14-2
Annual inspection checklist
Page 2 of 3
Serial No.:
Reg. Signs:
Year of Manuf.:
Canopy
Equipment
Adjustments cont.
S/N: ________
Minimum instrumentation
Control surface deflections
Locking mechanism
Additional Instrumentation
according to section 5
Emergency release funct.
Operating range marks
Air brake extension min.,
Window
Limit marks
147 mm inboard
Ventilation system
Vacuum flasks
Air brake locked, lateral gap
Canopy opener fixing
Pneumatic tubing
min. 1 mm at inner end
Gas strut operation
Instruments functioning
min.2.5 mm at outer end
LS latch (for jettison)
Total energy unit
Air brake locked, cockpit
Lift force:____ (8-15 kg)
Systems free from leaks
Lever min. 6mm from
(18-33 lbs)
Total pressure
stop #
Static pressure
Control surface friction
Rudder
T.E. system
Control surf. rear edge play
Finish condition
Landing gear locking
Shell
Electrical wiring
Trim system function
Ventilation openings
Battery + fitting
Harness condtion
Drive
Battery main fuse
Multiple point buckle funct.
Fixed bearing + washer
Tail fin battery
Op.Limit: ___________
Bearings
Tail fin battery main fuse
Ballast system function
Connecting means
Radio operation
Absolutely tight?
Landing gear
Antenna system
Undercarriage + axle
SWR: ______
General
Tyre
Communication check
Registration signs
Springing
Tow Hooks
Nationality marks
Bearings + joints
C.G. hook
Fireproof type placard
Folding strut overcenter
-Function + automatic rel.
External colour marking
Gas strut
-S/N: __________
Checklist
Folding strut preset load
-Op.Limit: __________
Minimum cockpit load
Doors
Nose hook function
Flight Manual
Drive rods
-S/N: __________
Maintenance Manual
Cockpit locking -
-Op.Limit: ___________
TN-AD status
Connecting means
Release cable end play
TB-AD-List up to date
Wheel brake system
existent with gear down
Certificate of Airworthiness
C.G. hook + drive
Data placard
Logbook notation
Ground conn. to contr. stick
Placards accord. to Maint.
Placard notations
Manual
Non-exist. of foreign matter
Baggage comp. cover
Compass deviation list
Wings flex number (support
Oxygen bottle receptacle
Adjustments
fuselage in front of landing
Fixed ballast at front/rear
Wings and horizontal tail
gear) ________ / Minute
Tangential play
Zero position of controls
Place: _________ Date: ________ Stamp: __________ Signature: _______________