DoorKing 1601 - Installation Site Preparation; New Concrete Pad; Trenching Existing Concrete

1601-065-P-12-19
6
1.3 Trenching Existing Concrete
Trench path(s) in the existing concrete wide enough for all the conduit runs. After
the conduit has been run, fill the trench with soil to bottom of existing concrete
and tamp down. Pour new concrete with a 4 inch pad height minimum (Reinforce
concrete if possible). Secure the mounting flange to concrete with 3/4” x 3” sleeve
anchors (not supplied). See illustration above for mounting operator.
1.2 New Concrete Pad
underground depth of the
concrete pad is determined by
soil conditions and local
building codes.
The operator(s) should be
installed with the access
door of the operator
opposite the traffic lane.
The operator(s) should be
installed with the access
door of the operator
opposite the traffic lane.
Remove breather
pin from gear
reducer AFTER the
operator has been
secured in place.
Concrete pad MUST be level.
Note: Bevel the edges of concrete
pad to eliminate water puddling
under the operator.
4” minimum
Reinforced concrete recommended.
Traffic Lane
Secure the mounting
flange to concrete
with 3/4” x 3”
sleeve anchors
(not supplied).
Traffic Lane
Access Door
Sleeve
Anchors
Conduit
C
L
A
S
S
C
E
R
T
I
F
I
E
D
T
O
C
A
N
/
C
S
A
C
2
2
.2
N
O
.
2
4
7
C
O
N
F
O
R
M
S
T
O
A
N
S
I
/
U
L
-
3
2
5
VE
HICU
L
AR
GA
T
E
O
PE
RA
T
OR
H
P
5
3
3
8
2
M
O
D
E
L
S
E
R
I
A
L
V
O
L
T
S
P
H
A
S
E
A
M
P
S
6
0
H
z
M
A
X
G
A
T
E
L
O
A
D
D
o
o
r
K
i
n
g
,
I
n
c
.
,
I
n
g
l
e
wo
o
d
,
C
A
Access
Door
4” height min.
Access Door
Approximate position
of conduit runs.
Inside
Operator
Mounting Flange
Mount
operator
centered
on pad.
3/4
3.5”
7.5”
12.375”
2.5”
7.25”
10.75”
11”
12”
23”
23”
Concrete Pad
Traffic Lane
CLASS
CERTIFIED TO
CAN/CSA C22.2 NO. 247
CONFORMS TO
ANSI/UL-325
VEHICULAR GATE OPERATOR
HP
53382
MODEL
SERIAL
VOLTS PHASE
AMPS 60 Hz
MAX GATE LOAD
DoorKing, Inc., Inglewood, CA
MOVING ARM can
cause vehicle damage,
serious injury or death.
STAY CLEAR of arm
at all times.
NO: Pedestrians
Bicycles
Motorcycles
WARNING
IMPORTANT: A barrier gate operator
installed WITHOUT any external
safety sensors CANNOT sense a
person under the raised arm and can
strike them while the arm is lowering.
DoorKing recommends installing an
external photo sensor directly under
the arm. See safety pages in front of
this manual for more information.
IMPORTANT: A barrier gate operator
installed WITHOUT any external
safety sensors CANNOT sense a
person under the raised arm and can
strike them while the arm is lowering.
DoorKing recommends installing an
external photo sensor directly under
the arm. See safety pages in front of
this manual for more information.
Moving
Gat
e Can Cau
se
Serious Injury or
D
eat
h
KEEP
C
LEAR!
G
ate may
move at
a
ny time
without prio
r warning.
Do not let
children operat
e
the gate
or play
in the gate area.
This entr
ance is for vehicles only.
Pedestrians
must use
separate ent
rance.
Moving Gate Can Cause
Serious Injury or Death
KEEP CLEAR! Gate may move at any time
without prior warning.
Do not let children operate the gate or play
in the gate area.
This entrance is for vehicles only.
Pedestrians must use separate entrance.