Fayat Group Dynapac CA25 - Maintenance, after the FIRST 50 Hours of Operation; Every 50 Hours of Operation (Weekly); Maintenance, Every 250;750 Hours of Operation

Maintenance – Maintenance schedule
02-17-2021 4812325897EN 63
Maintenance, after the FIRST 50 hours of
operation
Refer the figure "Revision and Inspection Points” to find
the page number of the sections referred to!
Pos. in
figure
Action
Comment
7
Replace the hydraulic oil filter
11
Replace the drum cartridge oil
30
Replace the oil in the drum gearbox
16
Steering hitch - Tightening
Every 50 hours of operation (Weekly)
Refer the figure "Revision and Inspection Points” to find
the page number of the sections referred to!
2
Drain the filter liquid
4
Check/clean the air filter elements
Replace as required
16
Lubricate the central joint
17
Lubricate the steering cylinders
30
Check the forward/reverse lever adjust
18
Check the tires pressure
19
Check the tightness of the wheel nuts
Maintenance, every 250/750 hours of
operation
Refer the figure "Revision and Inspection Points” to find
the page number of the sections referred to!
22
Replace the Diesel engine oil and oil filter
Refer to the engine manual
2
Replace the fuel filter and fuel pre-filter
Refer to the engine manual
34
Check the AC filter
20,11,14
Check the oil level in rear axle and drum
27
Check the battery
-
Check the bolted joints
-
Check the rubber elements
-
Cleaning the cartridge ventilation
28
Check and clean the radiator