Fayat Group Dynapac CA25 - Maintenance, Every 500 Hours of Operation; Maintenance, Every 1000 Hours of Operation

Maintenance – Maintenance schedule
02-17-2021 4812325897EN 64
Maintenance, every 500 hours of operation
Refer the figure "Revision and Inspection Points” to find
the page number of the sections referred to!
22
Replace the Diesel engine oil and oil filter
Refer to the engine manual
2
Replace the fuel filter and fuel pre-filter
Refer to the engine manual
4
Replace the primary air filter
34
Check the air conditioning filter
20,11,14
Check the oil level in rear axle and drum
27
Check the battery
-
Check the bolted joints
-
Check the rubber elements
-
Cleaning the cartridge ventilation
28
Check and clean the radiator
Maintenance, every 1000 hours of operation
Refer the figure "Revision and Inspection Points” to find
the page number of the sections referred to!
7
Replace the hydraulic fluid filter
34
Check the air conditioning filter
22
Replace the Diesel engine oil and oil filter
Refer to the engine manual
2
Replace the fuel filter and fuel pre-filter
Refer to the engine manual
4
Replace the primary and secondary air filter
20
Replace oil in rear axle differential
21
Replace oil in the rear axle planetary gears
11
Check the drum cartridge oil
27
Check the battery
-
Check the bolted joints
-
Check the rubber elements
-
Cleaning the cartridge ventilation
8,23
Drain the condensate from hydraulic oil reservoir and
fuel tank
-
Check the engine belt tension
Refer to the engine manual
30
Lubricate the forward/reverse lever setting
28
Check and clean the radiator
16
Steering hitch - Tightening