Fayat Group Dynapac CA25 - Maintenance, Every 2000 Hours of Operation

Maintenance – Maintenance schedule
02-17-2021 4812325897EN 65
Maintenance, every 2000 hours of operation
Refer the figure "Revision and Inspection Points” to find
the page number of the sections referred to!
7
Replace the hydraulic fluid filter
34
Check the air conditioning filter
22
Replace the Diesel engine oil and oil filter
Refer to the engine manual
2
Replace the fuel filter and fuel pre-filter
Refer to the engine manual
4
Replace the primary and secondary air filter
20
Replace oil in rear axle differential
21
Replace oil in the rear axle planetary gears
9
Replace the hydraulic oil
11
Replace the drum cartridge oil
12
Replace the oil in the drum gearbox
28
Replace engine coolant
27
Check the battery
-
Check the bolted joints
-
Check the rubber elements
-
Cleaning the cartridge ventilation
8,23
Drain the condensate from hydraulic oil reservoir and
fuel tank
-
Check the engine belt tension
Refer to the engine manual
30
Lubricate the forward/reverse lever
28
Check and clean the radiator
16
Steering hitch - Tightening