Table of Contents
iv Owner’s Manual for Stationary Generators
Section 5: Maintenance
Component Locations .......................................27
Access Panels ....................................................29
Removal .................................................................... 29
Installation ................................................................. 29
Service Maintenance Intervals .........................29
Remove From Service .......................................30
30 Hour Break-In ................................................31
Daily Maintenance (If Running Continuously)
....31
Schedule A Maintenance ..................................31
Preliminary Instructions ............................................. 31
Check Fuel Level and Fill .......................................... 31
Drain Fuel Filter and Check Fuel Lines/Hoses ......... 32
Check Coolant Level and Hoses ............................... 32
Check Radiator for Clogging ..................................... 32
Check Lubricating Oil Level ...................................... 33
Check Battery Condition/Fluid Level ......................... 33
Battery Replacement ................................................ 34
Check and Adjust V-Belt ........................................... 34
Adjust V-Belt Tension ............................................... 35
Replace Air Filter Element—2.5L Engine ........36
Replace Air Filter Element—2.2L Engine ........36
Lubricate Governor Rod Linkage
(2.5L Engine) ......................................................37
Final Instructions ....................................................... 37
Schedule B Maintenance ..................................37
Replace Lubricating Oil and Oil Filter ....................... 37
Drain Fuel Filter and Check Fuel Lines/Hoses ......... 38
Prime Fuel System .................................................... 38
Drain/Flush Coolant System ..................................... 38
Final Instructions ....................................................... 39
Schedule C Maintenance ..................................40
Return To Service ..............................................40
Section 6: Troubleshooting
Engine Troubleshooting ................................... 41
Controller Troubleshooting .............................. 42
Removal From Service During
Utility Outages.................................................... 43
Storage ............................................................... 43
Prepare For Storage ................................................. 43
Return From Storage ................................................ 44
Attention After Submersion ............................. 45
Attention After Fuel Spillage ............................ 45
Contaminated Fuel Disposal ............................ 45
To Next Page
Loading...
