■ Checking Radiator Hose and Clamp
Park the vehicle on a flat surface and raise the
cargo bed. Check to see if radiator hoses are
properly fixed every 200 hours of operation or
six months, whichever comes first.
1. If hose clamps are loose or water leaks,
tighten bands securely.
2. Replace hoses and tighten hose clamps
securely, if radiator hoses are swollen,
hardened or cracked. Replace hoses and
hose clamps every 2 years or earlier, if
checked and found that hoses are swollen,
hardened or cracked.
more than the boiling point, which is called
“Overheating”.
1. Stop the vehicle operation in a safe place
and keep the engine unloaded idling.
2. Don’t stop the engine suddenly, but stop it
after about 5 minutes of unloaded idling.
3. Keep yourself well away from the vehicle
for at least 10 minutes or while the steam is
blowing out.
4. Check to see if there is no danger such as
burning, get rid of the causes of
overheating according to the
“TROUBLESHOOTING” section of the
manual, and then start the engine again.
■ Checking Intake Air Line
1. Check to see if the hoses and hose clamps
are tight and not damaged.
2. If hoses and clamps are found to be worn
or damaged, replace or repair them at
once.
① Hose ② Hose joint
EVERY 300 HOURS
■ Checking Tire
To Next Page
Loading...
