Hitachi Zaxis 200LC User Manual

Contents
Page Page
Control Levers—Articulated Grapple/Valve Low Sulfur Diesel Fuel Conditioner.......... 3-1-1
in Head ............................ 2-2-13
Handling and Storing Diesel Fuel ........... 3-1-2
Control Lever Pattern Operation—
Alternative and Synthetic Lubricants......... 3-1-2
Machine Equipped With Excavator Front . . 2-2-14
Diesel Engine Oil ....................... 3-1-3
Backhoe Control Lever Pattern
Hydraulic Oil........................... 3-1-4
Conversion—Machine Equipped With
Swing Gearbox, Travel Gearbox and Pump
Excavator Front Only—Zaxis 200LC, 250 . . 2-2-15
Gearbox Oils......................... 3-1-5
Operating in Water and Mud ............. 2-2-16
Track Roller, Front Idler, and Carrier
Driving Up a Steep or Slippery Slope ....... 2-2-17
Roller Oil............................ 3-1-6
Lifting ............................... 2-2-17
Track Adjuster, Working Tool Pivots,
Lower Boom With Engine Stopped—Zaxis
Swing Bearing, and Swing Gear Grease.... 3-1-6
200LC, 250 ......................... 2-2-18
Cab and Riser Tilt Power Pack Oil .......... 3-1-7
Lower Boom With Engine Stopped—
Zaxis 350 .......................... 2-2-19
Maintenance—Periodic Maintenance
Parking the Machine.................... 2-2-20
Service Your Machine at Specified Intervals. . . 3-2-1
Loading Machine on a Trailer ............. 2-2-21
Check the Hour Meter Regularly ........... 3-2-1
Cab Tilting Procedure................... 2-2-22
Prepare Machine for Maintenance .......... 3-2-1
Shipping Dimensions—Zaxis 200LC
Open Access Doors for Service ............ 3-2-2
Forester Road Builder With 2.39 m
Open Engine Hood for Service ............. 3-2-2
(7 ft 10 in.) Track Width, Side Entry Cab. . . 2-2-24
Fuel Tank ............................. 3-2-2
Shipping Dimensions—Zaxis 200LC
Fluid Analysis Program Test Kits and
Forester Live Heel Grapple With 2.92
3-Way Coolant Test Kit ................. 3-2-4
m (9 ft 7 in.) Track Width, Rear Entry
Maintenance and Repair Record
Cab............................... 2-2-26
Keeping System ...................... 3-2-5
Shipping Dimensions—Zaxis 200LC
Forester Articulated Grapple, Rear Entry
Cab............................... 2-2-28
Maintenance—As Required
Shipping Dimensions—Zaxis 250
Clean Fuel Tank Inlet Screen .............. 3-3-1
Forester Road Builder, Side Entry Cab .... 2-2-30
Drain Fuel Tank Sump ................... 3-3-1
Shipping Dimensions—Zaxis 250
Clean Radiator Air Inlet Screen ............ 3-3-2
Forester Road Builder, Side Entry Cab—High
Drain Water Separator ................... 3-3-2
Drawbar ........................... 2-2-31
Bleed Air From Fuel System............... 3-3-3
Shipping Dimensions—Zaxis 250
Clean Air Cleaner Dust Valve.............. 3-3-3
Forester Live Heel Grapple, Rear Entry
Check Track Sag ....................... 3-3-4
Cab............................... 2-2-33
Adjust Track Sag ....................... 3-3-5
Shipping Dimensions—Zaxis 250
Windshield Washer Fluid Level............. 3-3-6
Forester Butt-N-Top Grapple, Rear Entry
Check Hydraulic Oil Level in Cab Tilt
Cab............................... 2-2-34
Power Pack ......................... 3-3-6
Shipping Dimensions—Zaxis 350
Vent Hydraulic Oil Tank Pressure........... 3-3-7
Forester Road Builder, Side Entry Cab .... 2-2-35
Replace Oil Cooler Debris Screen—
Shipping Dimensions—Zaxis 350
Zaxis 200LC, Zaxis 250 ................ 3-3-8
Forester Road Builder, Side Entry Cab—High
Drawbar ........................... 2-2-36
Maintenance—Every 10 Hours or Daily
Shipping Dimensions—Zaxis 350
Check Engine Oil Level .................. 3-4-1
Forester Live Heel Grapple, Rear Entry
Check Recovery Tank Coolant Level ........ 3-4-2
Cab............................... 2-2-37
Check Hydraulic Oil Level ................ 3-4-3
Shipping Dimensions—Zaxis 350
Grease Working Tool Pivots ............... 3-4-5
Forester Butt-N-Top Grapple, Rear Entry
Cab............................... 2-2-38
Towing Machine ....................... 2-2-39
Maintenance—Every 50 Hours
Grease Swing Bearing ................... 3-5-1
Maintenance—Machine
Continued on next pageDiesel Fuel ............................ 3-1-1
ii 081407
PN=2

Hitachi Zaxis 200LC Specifications

General

Brand	Hitachi
Model	Zaxis 200LC
Category	Excavators
Language	English