ILMOR MV8 570 - MAINTENANCE; MAINTENANCE SCHEDULE

Ilmor High-Performance Marine, LLC
© 7/2013, Version 1.0
7-1
Section 7
MAINTENANCE
In addition to the routine matters addressed earlier, there are a number of
other maintenance matters that require periodic attention.  e following
table indicates the maintenance schedule:
MAINTENANCE SCHEDULE
Item Service
Every
25 hrs
Every
50 hrs
Every
100 hrs/
Annually#
Engine oil and fi lter Change
X X
Engine coolant* Check
X**
Power steering fl uid* (if equipped) Check
X X**
Serpentine belt Inspect
X X**
Sea pump – MV10
Basic Rebuild
X**
Complete Rebuild*
X**
Sea pump – MV8-570 Basic Rebuild
X**
Fuel/water separator Replace
X X
High-pressure fuel fi lter Replace
X
Air fi lter/spark arrestor Change
X
Rubber hoses Inspect
X**
Spark plugs* Replace
X
Spark plug wires* Inspect
X
Shaft alignment* Inspect
X
Engine and transmission coolers Inspect
X
Zinc anodes Inspect
X**
# Whichever comes fi rst.
* Services best accomplished by a certifi ed Ilmor dealer.
** Replace sooner if regular checks indicate wear or damage.
Ilmor recommends that the maintenance requirements be performed by a
certi ed Ilmor dealer. Service technicians there have the proper equipment,
training and resources to best meet your service needs. Please note that
routine maintenance is not covered by the Ilmor High-Performance Marine
Limited Warranty. For details, consult the limited warranty statement.