Kohler Decision-Maker 3000 Operation

116 TP-6694 9/20
Section or Publication Reference*
Engine
Eng. O/M
Eng. S/M
S/S
I/M
I/M
Eng. S/M
Eng. S/M
--
Eng. O/M, Eng. S/M
Eng. O/M, Eng. S/M
* Sec./Section
—numbered section of this manual; ATS
—Automatic Transfer Switch; Eng.
—Engine; Gen.
—Generator Set; Alt.
—Alternat
or; I/M
—Installation Manual;
O/M
—Operation
Manual; S/M
—Service Manual; S/S
—Spec Sheet; O/S/M
—Operation/Service Manual; W/D
—Wiring Diagram
† Have an authorized service distributor/dealer perform this service.
Recommended Actions
Clean or replace the filter element.
Check the compression. †
Reduce the
electrical load. See the generator set
installation manual for wattage specifications.
Inspect the exhaust system. Replace the inoperative exhaust system components. †
Inspect the exhaust system. Tighten the loose exhaust system components. †
Adjust the
governor. †
Adjust the valves. †
Tighten all loose hardware.
Check the ignition system (spark plugs, spark plug wires, etc.).
Troubleshoot the engine ECM and/or sensors.
Probable Causes
Air cleaner clogged.
Compression weak.
Engine overload.
Exhaust
system leak.
Exhaust system not securely installed
Governor inoperative.
Valve clearance incorrect.
Vibration excessive.
Ignition system inoperative (gas models only)
Engine ECM and/or sensors.
Trouble Symptoms
Exercise run time
and/or event
records inoperative
x
Displays error
message/locks up
x
Excessive or
abnormal noise
x
x
x
x
x
x
High fuel
consumption
x
x
x
x
Low oil pressure
Overheats
x
x
Lacks power
x
x
x
x
x
Stops suddenly
x
No or low output
voltage
x
x
Starts hard
x
x
x
x
Cranks but does
not start
x
x
x
x
Does not crank
x

Kohler Decision-Maker 3000 Specifications

General

Brand	Kohler
Model	Decision-Maker 3000
Category	Controller
Language	English