Mahindra 2810 - Page 151

Counter measuresProblems and probable causes
3. Free play of steering wheel
-Adjust fluid level and pressure properly
-Wash
-Check column and adjust
2) Depressed control set
(1) Excessive fluid and pressure
(2) Depressed by foreign material
(3) Depressed from external when assemble
with column
-Replace spring
1)Too low elastic of centering spring
( Remove P port pipe line and check left and
right turning)
(1)Damaged spring or poor elastic
4. Steering wheel resistance with turning
-Replace column
-Wash,and Adjust fluid level and pressure
properly
-Deflate the air
-Adjust column
-Replace column and replenish oil
(1)Worn of spline gear column
(2)Depressed control set
(3)Air trapped in cylinder and pipe line
(4)Excessive backlash column
(5)Poor turning of column,or wear of bearing .
5.Too much free play of steering wheel(Rough touching on tire causes vibration)
-Deflate the air
-Replace
(1)Air trapped in steering cylinder and pipe line.
(2)Worn ball bearing
6.Free play steering wheel
-Replenish oil
-Replace oil seal and cylinder
-assemble spacer parts.
(1)Insufficient oil in the tank
(2)Worn,damage steering cylinder
(3)Loose spacer in unit
7.Kick-back of steering wheel
-Adjust check valve
-consult workshop
(1)Loose check valve in "P" port or don't
operate
(2) Trouble in system
8-14