Manitowoc Grove RT600E - Page 67

3-1
RT600E OPERATOR MANUAL OPERATING CONTROLS AND PROCEDURES
3
Published 05-02-2018 Control # 088-10
GROVE
SECTION 3
OPERATING CONTROLS AND PROCEDURES
SECTION CONTENTS
Controls And Indicators. . . . . . . . . . . . . . . . . . . . . 3-2
Hand Throttle Control . . . . . . . . . . . . . . . . . . . . . . 3-2
Transmission Oil Temperature Gauge . . . . . . . . . 3-2
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Ignition Switch. . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Tachometer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Engine Coolant Temperature Gauge . . . . . . . . . . 3-2
Foot Throttle Pedal . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Crane Function Power Switch. . . . . . . . . . . . . . . . 3-8
Transmission Shift Lever . . . . . . . . . . . . . . . . . . . 3-8
Telescope or Auxiliary Hoist Control Lever
(Single Axis Option) . . . . . . . . . . . . . . . . . . . . . . . 3-8
Swing Control Lever (Single Axis Option). . . . . . . 3-8
Swing And Telescope or Swing and Auxiliary
Hoist Control Lever (Dual Axis Option). . . . . . . . . 3-8
Water In Fuel Indicator . . . . . . . . . . . . . . . . . . . . . 3-8
Rear Steer Control Switch . . . . . . . . . . . . . . . . . . 3-8
Auxiliary Hoist Speed Selector Switch
(Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9
Boom Lift Control Lever (Single Axis Option) . . . 3-10
Main Hoist Control Lever (Single Axis Option) . . 3-10
Boom Lift And Main Hoist Control Lever
(Dual Axis Option). . . . . . . . . . . . . . . . . . . . . . . . 3-10
Telescope Control Foot Pedal (Optional) . . . . . . 3-10
Hoist Rotation Indicators. . . . . . . . . . . . . . . . . . . 3-10
Drive Axle Selector Switch . . . . . . . . . . . . . . . . . 3-10
Outrigger Control Switches . . . . . . . . . . . . . . . . . 3-10
Outriggers Extend/Retract Switch. . . . . . . . . . . . 3-10
Swing Brake Control Switch . . . . . . . . . . . . . . . . 3-10
Swing Brake Pedal . . . . . . . . . . . . . . . . . . . . . . . 3-10
Service Brake Foot Pedal . . . . . . . . . . . . . . . . . . 3-10
Low Brake Pressure Indicator. . . . . . . . . . . . . . . 3-11
Park Brake Control Switch . . . . . . . . . . . . . . . . . 3-11
Turntable Lock Control (Pin Type) . . . . . . . . . . . 3-11
360 Degree Swing Lock Control (Positive
Lock Type) (Optional) . . . . . . . . . . . . . . . . . . . . . 3-11
Rated Capacity Limiter (RCL) and Work
Area Definition System Control Panel. . . . . . . . . 3-11
Low Steer Pressure Indicator (CE Units) . . . . . . 3-11
Transmission Service Indicator (XMSN) . . . . . . . 3-11
Headlights Switch . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Work Light Switch . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Cab Circulating Fan . . . . . . . . . . . . . . . . . . . . . . 3-11
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Hazard Lights Switch . . . . . . . . . . . . . . . . . . . . . . 3-11
Boom Light Switch (Optional) . . . . . . . . . . . . . . . 3-11
Turn Signal Lever and Windshield
Wiper/Washer Controls . . . . . . . . . . . . . . . . . . . . 3-12
Cab Dome Light. . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Skylight Wiper (Not Shown). . . . . . . . . . . . . . . . . 3-12
Bubble Level Indicator . . . . . . . . . . . . . . . . . . . . . 3-12
Air Conditioner Control Switch (Optional) . . . . . . 3-12
Heat Control Knob . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Fan Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Defroster Switch . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Fire Extinguisher . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Defroster Fan. . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Windshield Wiper. . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Axle Differential Lock Control Switch (Optional) . 3-12
Right Turn Signal Indicator . . . . . . . . . . . . . . . . . 3-12
Left Turn Signal Indicator. . . . . . . . . . . . . . . . . . . 3-13
Rear Wheels Not Centered Indicator. . . . . . . . . . 3-13
Hydraulic Boost Switch . . . . . . . . . . . . . . . . . . . . 3-13
Hoist 3rd Wrap Indicator (Optional CE Units) . . . 3-13
Main Hoist Speed Selector Switch. . . . . . . . . . . . 3-13
12 VDC Accessory Outlet . . . . . . . . . . . . . . . . . . 3-13
Spotlight (Optional) . . . . . . . . . . . . . . . . . . . . . . . 3-13
Fuse Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Wait To Start Indicator . . . . . . . . . . . . . . . . . . . . . 3-13
Engine Diagnostics Switches. . . . . . . . . . . . . . . . 3-13
Engine Stop Indicator . . . . . . . . . . . . . . . . . . . . . 3-13
Engine Warning Indicator . . . . . . . . . . . . . . . . . . 3-14
Engine Service Indicator . . . . . . . . . . . . . . . . . . . 3-14
Throttle Mode Switch . . . . . . . . . . . . . . . . . . . . . . 3-14
Electronic System Diagnostic Indicator . . . . . . . . 3-14
Work Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-14
-29°C Indicator (Optional) . . . . . . . . . . . . . . . . . . 3-14
Strobe Light or Beacon (Not Shown) . . . . . . . . . . 3-14
RCL Lockout (All Units) and RCL Lockout
Alarm (CE Units) (Not Shown). . . . . . . . . . . . . . . 3-14
Buzzer (Not Shown). . . . . . . . . . . . . . . . . . . . . . . 3-14
Hourmeter (Not Shown). . . . . . . . . . . . . . . . . . . . 3-14
Skylight Wiper (Not Shown). . . . . . . . . . . . . . . . . 3-14
Backup Alarm (Not Shown) . . . . . . . . . . . . . . . . . 3-14
Data Link and Service Connector (Not Shown). . 3-14
Anemometer (Not Shown) . . . . . . . . . . . . . . . . . . 3-14
Emergency Exit . . . . . . . . . . . . . . . . . . . . . . . . . . 3-14
Operating Procedures. . . . . . . . . . . . . . . . . . . . . . 3-15
227415