Mec 85-J - Table of Contents

Page ii 85
-
J - Operator’s Manual - 95803
January 2024
Table of Contents
Section 1 - Introduction . . . . . . . . . . . . . . . . 1
Introduction � � � � � � � � � � � � � � � � � � � � � 1
Section 2 - Safety . . . . . . . . . . . . . . . . . 2
Safety � � � � � � � � � � � � � � � � � � � � � � � 2
Safety Alert Symbols & Fall Protection � � � � � � � � � � � � � � 3
Section 3 - Specications . . . . . . . . . . . . . . . 4
Specications � � � � � � � � � � � � � � � � � � � � � 4
Section 4 - Hazards . . . . . . . . . . . . . . . . . 5
Electrocution Hazard � � � � � � � � � � � � � � � � � � � 5
Energized Conductor Contact Hazard� � � � � � � � � � � � � � � 6
Tip-over Hazards � � � � � � � � � � � � � � � � � � � � 8
Fall & Collision Hazards � � � � � � � � � � � � � � � � � � 10
Additional Safety Hazards
� � � � � � � � � � � � � � � � � � 11
Section 5 - Controls & Components . . . . . . . . . . . . 12
Component Locations � � � � � � � � � � � � � � � � � � � 12
Platform Controls
� � � � � � � � � � � � � � � � � � � � 13
Base Controls � � � � � � � � � � � � � � � � � � � � � 16
Section 6 - Workplace Inspection . . . . . . . . . . . . . 18
Workplace Inspection � � � � � � � � � � � � � � � � � � � 18
Section 7 - Operating Instructions & Pre-Operation Function Tests. . . . 19
Operating Instructions & Pre-Operation Function Tests � � � � � � � � � � 19
Base Controls Operation & Pre-Operation Functions Test � � � � � � � � � 21
Platform Control Operation & Pre-Operation Functions Test
� � � � � � � � � 26
Platform Control Panel� � � � � � � � � � � � � � � � � � � 27
Platform Operations Test � � � � � � � � � � � � � � � � � � 28
Drive Control Lever Operation
� � � � � � � � � � � � � � � � � 30
Auxiliary Power System & Test
� � � � � � � � � � � � � � � � 35
Section 8 - Maintenance. . . . . . . . . . . . . . . . 37
Maintenance � � � � � � � � � � � � � � � � � � � � � 37
Supporting the Boom Assembly � � � � � � � � � � � � � � � � 39
Pre-Start Inspection Checklist
� � � � � � � � � � � � � � � � � 40
Frequent Inspection Checklist
� � � � � � � � � � � � � � � � � 41
Maintenance Inspection Report � � � � � � � � � � � � � � � � 42
Lubrication� � � � � � � � � � � � � � � � � � � � � � 43
Section 9 - Troubleshooting . . . . . . . . . . . . . . 44
Troubleshooting � � � � � � � � � � � � � � � � � � � � 44
Section 10 - Decals . . . . . . . . . . . . . . . . . 45
Decals � � � � � � � � � � � � � � � � � � � � � � � 45