Starter Motor Will Not Crank the Engine
POSSIBLE CAUSES
•
Lanyard stop switch not in RUN position.
•
Open clean power harness circuit fuse. Refer to Maintenance section.
• Remote control is not shifted to the neutral position.
•
Shift actuator failure. Turn ignition key switch OFF to reset and then start
the engine.
• Weak battery or battery connections are loose or corroded.
• Ignition key switch failure.
• Wiring or electrical connection faulty.
• Starter motor solenoid or starter relay failure.
Engine Will Not Start
POSSIBLE CAUSES
•
Incorrect starting procedure. Refer to Operation section.
• Old or contaminated gasoline.
• Fuel is not reaching the engine.
• Fuel tank is empty.
• Fuel tank vent not open or restricted.
• Fuel line is disconnected or kinked.
•
Fuel filter is obstructed. Refer to Maintenance section.
• Fuel pump failure.
• Fuel tank filter obstructed.
• Ignition system component failure.
•
Spark plugs fouled or defective. Refer to Maintenance section.
Engine Starts But Will Not Shift Into Gear
• Throttle only mode is engaged.
•
Shift actuator failure. Turn ignition key switch OFF to reset and then start
the engine.
Engine Runs Erratically
POSSIBLE CAUSES
• Overheating—warning horn not working.
• Low oil pressure. Check oil level.
•
Spark plugs fouled or defective. Refer to Maintenance section.
• Incorrect setup and adjustments.
• Fuel is being restricted to the engine.
TROUBLESHOOTING
eng 133
To Next Page
Loading...
Need help?
General
