Napoleon BL36NTE User Manual

EN
FR
PG
59
W415-1442 / C / 06.06.16
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE
INSTALLATION AND
OPERATING INSTRUCTIONS
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone (705)721-1212 • Fax (705)720-9081 • www.napoleonfi replaces.com • hearth@napoleonproducts.com
1.28F
$10.00
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
!
DANGER
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance
and shall be installed for the protection of children
and other at-risk individuals.
SAFETY INFORMATION
!
WARNING
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbour’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
fi re department.
- Installation and service must be performed by a
qualifi ed installer, service agency or the supplier.
This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless a
certifi ed kit is used.
If the information in these instructions
are not followed exactly, a fi re or
explosion may result causing property
damage, personal injury or loss of life.
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.
Decorative Product: Not for use as a heating appliance.
CONFORMS TO AMERICAN NATIONAL STANDARDS: ANSI Z21.50, CERTIFIED TO CANADIAN CSA 2.22 FOR VENTED GAS FIREPLACES.
BL36PTE
PROPANE GAS MODEL
BL36NTE
NATURAL GAS MODEL
SAFETY BARRIER

Napoleon BL36NTE Specifications

General

Brand	Napoleon
Model	BL36NTE
Category	Indoor Fireplace
Language	English

Summary

SAFETY INFORMATION

DANGER HOT GLASS

Warning about hot glass and burn risks, emphasizing not to touch until cooled.

INSTALLATION OVERVIEW

INTRODUCTION

GENERAL INSTRUCTIONS

Key operating and installation guidelines and safety precautions.

VENTING

VENTING LENGTHS AND COMPONENTS

Details on required vent components, lengths, and suppliers.

TYPICAL VENT INSTALLATION

Illustrates standard vertical vent pipe installation procedures and clearances.

MINIMUM AIR TERMINAL LOCATION CLEARANCES

Specifies minimum clearances for air terminal locations based on installation type.

TOP EXIT HORIZONTAL TERMINATION

TOP EXIT VERTICAL TERMINATION

COLLAR INSTALLATION

Step-by-step instructions for installing the vent collar assembly.

INSTALLATION

WALL AND CEILING PROTECTION

Instructions for protecting walls and ceilings from heat and fire.

HORIZONTAL INSTALLATION

Detailed steps for installing vent systems through an exterior wall.

VERTICAL INSTALLATION

Detailed steps for installing vent systems through a roof.

USING FLEXIBLE VENT COMPONENTS

Instructions for using flexible vent pipes and their connections.

USING RIGID VENT COMPONENTS

VERTICAL THROUGH EXISTING CHIMNEY

GAS INSTALLATION

Procedures and safety precautions for connecting the gas supply.

FRAMING

MINIMUM FRAMING DIMENSIONS

MINIMUM CLEARANCES TO COMBUSTIBLES

MINIMUM ENCLOSURE CLEARANCES

INSTALLATION OF NON-COMBUSTIBLE BOARD

MINIMUM COMBUSTIBLE MANTEL CLEARANCES

OPERATION

SAFETY BEFORE LIGHTING

Critical safety checks and information before attempting to light the appliance.

WHAT TO DO IF YOU SMELL GAS

Emergency procedures to follow if a gas leak is detected.

LIGHTING INSTRUCTIONS

Step-by-step guide for lighting the appliance safely.

ADJUSTMENT

PILOT BURNER ADJUSTMENT

VENTURI ADJUSTMENT

MAINTENANCE

SAFETY WIRE LABELING

ANNUAL MAINTENANCE

REPLACEMENTS

TROUBLESHOOTING

TROUBLESHOOTING SYMPTOMS

Common issues and their corresponding test solutions for appliance malfunction.

WARRANTY

WARRANTY CONDITIONS AND LIMITATIONS