Nordson FoamMelt 200 - Page 8

Table of Contents
vi
E 2015 Nordson Corporation
All rights reserved
321222_06
Issued 04/2015
Manual
Drive Shaft Face Seal Replacement A 9-6.....................
Drive Assembly Installation A 9-8.............................
Installing the Alignment Plate A 9-8........................
Installing the Drive Assembly A 9-9.........................
Motor and Motor Plate Installation A 9-10......................
Motor Plate A 9-10.......................................
Motor A 9-10............................................
Pulley Installation and Alignment A 9-11.......................
4. Pressure Control Valve A 9-12..................................
Replacing the Pressure Control Valve A 9-12..................
Rebuilding the Pressure Control Valve A 9-14..................
Preparation A 9-14.......................................
Disassembly A 9-14......................................
Cleaning and Inspection A 9-16............................
Assembly A 9-16.........................................
5. Density Controller Rebuild A 9-17...............................
6. Pressure Relief Valve Replacement A 9-18.......................
7. Drain Valve Replacement A 9-20...............................
8. Hose Connector O-ring Replacement A 9-21.....................
9. Gas Repair A 9-23............................................
Preparation A 9-23.........................................
Gas Pressure Control Panel A 9-24...........................
Removal A 9-24.........................................
Installation A 9-24........................................
Gas Pressure Regulator Replacement A 9-25..................
Gas Pressure Gauge Replacement A 9-26....................
Reedex Valve Replacement A 9-27...........................
Gas Pressure Switch Replacement A 9-27.....................
Gas Pressure Check Valve Replacement A 9-28...............
Pressure Transducer Assembly Replacement A 9-28...........
Removal A 9-29.........................................
Installation A 9-30........................................
10. I/O Board Replacement A 9-30.................................
Section A 9
Repair
(contd)