Numatic HGB 3045 - Recommended Spare Parts; Trouble Shooting

32
T 01460 68600
Spare Parts
Trouble Shooting
Failure to rectify the problem or in the event of a breakdown contact your Numatic dealer or
Numatic Technical helpline +44 (0)1460 269268
PROBLEM CAUSE SOLUTION
Machine will not operate Missing or blown fuses
Low battery charge
Machine is connected and charging
Fit or replace fuse (page 5)
Charge batteries (page 13 / 14)
Take o charge (page 13)
Vacuum will not operate Waste water tank full
Check fuse
Empty waste water tank (page 11)
Check fuse (page Page 5)
Poor water pick-up Waste water tank full
Clogged / blocked vacuum hose
Loose hose connections
Debris basket lter clogged / blocked
Separator lter clogged / blocked
Poor separator seal
Damaged separator seal
Damaged / split vacuum hose
Damaged oor tool blades
Low battery charge
Empty waste water tank (page 11)
Remove and clean (page 11)
Push tight connections (page 7)
Remove and clean (page 11)
Remove and clean (Page 11)
Clean and ret (page 11)
Renew (contact service dept)
Renew (contact service dept)
Renew (contact service dept)
Re-charge batteries (page 13 / 14)
No brush / scrub function No brushes tted
Check fuse
Check and t (page 6)
Check fuse (page Page 5)
Little or no water ow Clean water tank empty
Clean water tank lter blocked / clogged
Water ow not on
Brush deck raised
Fill clean water tank (page 7)
Remove and clean (11)
Switch on water ow (Page 9)
Lower brush deck (page 9)
Machine just ‘stops’ while
operating
Too much load on the brush system Decrease the brush load to best suit the
oor type.
Part No. BRUSHES Part No. HOSES
606028 550 mm Polyscrub Brush 903341 Hose Closure (Bottom Tank)
606550 550 mm Nyloscrub Brush 903341 Hose Closure ( Filling Hose)
606551 550 mm Long Life Brush 900903 Hose Closure (Top Tank)
900526 500 mm NuLoc2 Drive Board
Part No. GENERAL PARTS
606203 450mm Polyscrub Brush 221091 20 Amp Maxi Fuse (VAC)
606204 450mm Nyloscrub Brush 230104 30 Amp Maxi Fuse (Brush)
606306 450mm Longlife Brush 221047 40 Amp Maxi Fuse (Battery)
900525 400mm NuLoc2 Drive Board 221107 50 Amp Maxi Fuse (Battery Traction)
Part No. SQUEEGEE
903066 2.5 Amp Handle Fuse
903281 Red Squeegee Knob 903736 24v Contactor
215006 Squeegee Castor Wheel 903542 Grit Filter Basket (Red)
606319 Squeegee Castor Assembly Set 208888 (CWF) Clean Water Filter (Complete)
900518 Squeegee 650 Blade Set 208827
CWF Strainer Base Moulding
903486 Complete 650 Squeegee Assembly 208830 CWF Strainer Gasket
900519 Squeegee 750 Blade Set 208889 CWF Extended Strainer 50 Mesh Screen
904699 Complete 750 Squeegee Assembly 208890
CWF 68mm Extended Strainer Clear Bowl
206953 Detent Pin 208638 160mm Rear Wheel
Part No. FILTERS
220386 Charging Lead (V17 - UK)