4 | Bellavista® B36XTCE-11 Gas Fireplace
table of contents
On Demand Pilot Light (seven day safety timer) ...................2
Copy of Safety Decal .....................................................5
Decal location ................................................................5
MA Code - CO Detector ................................................6
Unit Dimensions ............................................................7
Important Message ....................................................10
Before You Start ...........................................................10
General Safety Information ..........................................10
Lighting Procedure ......................................................11
Copy of Lighting Plate Instructions ..............................12
Proflame I Remote Control Operating Instructions ......13
Gas Installation Checklist ..............................................8
Installation Checklist ....................................................17
Locating Your Gas Fireplace ........................................17
Clearances ..................................................................18
Mantel Clearances .......................................................19
Mantel Leg Clearances ................................................20
Non-Combustible Requirements..................................20
Framing .......................................................................21
Framing & Finishing .....................................................22
Tile Finish ............................................................22
Clean Finish .........................................................22
Unit Assembly Prior to Installation ...............................24
Top Standoff Assembly ................................................24
Nailing Strips........................................................24
Conversion to Top Vent ................................................25
Vent Restrictor, Baffle & Heat Deflector Installation ....27
Venting Introduction .....................................................27
Exterior Vent Termination Requirements .....................28
Top Vent Reducer Installation-from 5"x8" to 4"x6-5/8" . 29
Venting - Direct Vent System (Flex) ...........................30
Vertical Flue Extension Kit (part #946-756) .................32
Ceiling Firestop / Firestop Spacer (part #946-757) .....32
Rigid Pipe Cross Reference Chart only .......................33
Venting Arrangements - horizontal terminations . 37
Flex Vent or Rigid Pipe 5" x 8" .............................37
Horizontal Terminations ...............................................38
Flex Vent 5" x 8" ..................................................38
Rigid Pipe 5" x 8" .................................................39
AstroCap XL & Rigid Rear Vent Kit - Corner Install .....40
Rigid Pipe 5" x 8" .................................................40
Venting Arrangements Horizontal Terminations ...41
Rigid Pipe 4" x 6-5/8" ...........................................41
Horizontal or Vertical Terminations ......................42
Rigid Pipe 4" x 6-5/8" ...........................................42
Horizontal Terminations ...............................................43
Two (2) 90
o
Elbows (Rigid Pipe 4" x 6 - 5/8") ...............43
Horizontal Terminations ...............................................43
Three (3) 90
o
Elbows (Rigid Pipe 4" x 6 - 5/8") ............43
Venting Arrangements - Vertical Terminations .....44
Vertical Terminations ..................................................45
Three (3) 90
o
Elbows (Rigid Pipe 4" x 6 - 5/8") ............45
Venting Arrangements .........................................46
With Co-linear Flex System .................................46
Vertical Terminations ...........................................47
Co-linear Flex System Into Masonry Fireplaces . 47
Unit Installation with Horizontal Termination ...............48
4" x 6-5/8" or 5" x 8" Venting .......................................48
Unit Installation with Horizontal Termination ...............49
5" x 8" Venting .............................................................49
Unit installation with Vertical Termination .....................50
4" x 6-5/8" Venting .......................................................50
Gas Line Installation ....................................................50
Pilot Adjustment ...........................................................51
High Elevation ..............................................................51
885 S.I.T. Valve Description .........................................51
Gas Pipe Pressure Testing ..........................................51
Conversion Kit #578-977 from NG to LP .....................52
Brick Panel Installation ................................................53
Optional Black Enamel Panel Installation ....................54
Log Set Installation ......................................................55
Aeration Adjustment ....................................................58
Wiring Diagram ............................................................58
Installing the Optional Fan ..........................................59
Wiring Diagram with Optional Fan ...............................60
Optional Wall Thermostat Installation ..........................61
Safety Screen Removal / Installation ..........................62
Flush Glass Door Installation .......................................63
Operating Instructions .................................................64
First Fire ......................................................................64
Normal Operating Sounds of Gas Appliances .............64
Copy of Lighting Plate Instructions ..............................65
Maintenance Instructions ............................................66
Log Replacement ........................................................66
Glass Gasket ...............................................................66
Door Glass ...................................................................66
Glass Replacement .....................................................66
Removing Valve ...........................................................67
Installing Valve .............................................................67
Gas Maintenance ........................................................68
Main Assembly ............................................................69
Burner Assembly .........................................................71
Warranty ......................................................................72
OWNER'S INFORMATION
INSTALLER'S INFORMATION
To Next Page
Loading...
