SOLIS 50 - Trouble Shooting

81
Operator Manual
10. TROUBLE SHOOTING
PROBLEM POSSIBLE CAUSE
REMEDY
ENGINE
Engine not starting
Engine not run in
proper way
More oil
consumption
Engine not giving
maximum power
Engine abnormal
noise
Oil pressure gauge
shows warning
Engine Over
Heating
Wrong way of starting engine
No fuel
Air trapped in fuel system
Checking of fuel system
Fuel injector faulty
Pull to lever knob in pulling condition
Fuel filter choke
Fuel filter choke
Low quality of oil
Choking of fuel system
Fuel injectors faulty
Oil level is more than maximum level
Oil quality is not good
Leakage of oil
Heavy load on engine
Air cleaner dirty
Fuel filter choke
Engine overheating
Engine operating temperature is less
Valve clearance not proper
Throttle system not working properly
Oil level less
Oil pressure less
Engine is overheated
Improper tappet setting
Oil level is less
Oil quality is not good
Oil pump not working
Radiator cap faulty
Choked radiator fins
Engine gets overload
Oil level is less
Coolant level is less
Slippage of fan belt
Thermostat faulty
Choking of cooling system
Water temp. Gauge not working
Use proper way of starting
Check oil level
Bleed the fuel system
Contact your dealer
Replace
Return it to its proper position
Replace filters
Replace filters
Drain diesel from tank and fill clean diesel
Check fuel system
Replace fuel injector
Keep oil level up to mark
Use genuine oil
Check and repair
Decrease load or shift in low gear
Clean air cleaner
Replace filter
Check cooling system
Check thermostat
Adjust through authorized dealer.
Check & repair through authorized dealer.
Top up
Check through authorized dealer
Check and find reason
Adjust through authorized dealer
Top up oil up to level
Use genuine engine oil
Check and repair through authorized dealer
Replace with new one
Clean it
Decrease load or shift to low gear
Top up to level
Check level and leakage of system and top up
Check belt tension
Replace
Clean the cooling system
Check through dealer and faulty replace