Overhaul Manual
O-360 and IO-360 Series Engines
SAFETY ADVISORY
WARNING: BEFORE MATERIALS CALLED OUT IN THIS PUBLICATION ARE USED, KNOW THE
HANDLING, STORAGE AND DISPOSAL PRECAUTIONS RECOMMENDED BY THE
MANUFACTURER OR SUPPLIER. FAILURE TO COMPLY WITH THE
MANUFACTURERS' OR SUPPLIERS’ RECOMMENDATION CAN RESULT IN PERSONAL
INJURY.
The user must know the manufacturer or supplier information and keep to the procedures,
recommendations, warnings and cautions set forth for the use, handling, storage, and disposal of materials.
The WARNINGS used in this manual inform the user about dangerous materials or equipment that can
cause injury; they do not replace the manufacturer's instructions.
This Safety Advisory has all the warnings included in this manual.
WARNING: OPERATION OF A DEFECTIVE ENGINE WITHOUT A PRELIMINARY EXAMINATION CAN
CAUSE FURTHER DAMAGE TO A DISABLED COMPONENT AND POSSIBLE INJURY TO
PERSONNEL. MAKE SURE THOROUGH INSPECTION AND TROUBLESHOOTING
PROCEDURES ARE ACCOMPLISHED. THIS WILL HELP TO PREVENT INJURIES TO
PERSONNEL AND/OR DAMAGE TO THE EQUIPMENT.
WARNING: FUEL IS TOXIC AND FLAMMABLE. DO NOT BREATHE VAPORS. USE INA A WELL
VENTILATED AREA FREE FROM SPARKS, FLAME, OR HOT SURFACES.AVOID EYE
AND SKIN CONTACT. PUT ON SPLASH GOGGLES, SOLVENT-RESISTANT GLOVES,
AND OTHER PROTECTIVE GEAR. IN CASE OF EYE CONTACT, FLUSH WITH WATER
FOR 15 MINUTES AND SEEK MEDICAL ATTENTION. IN CASE OF SKIN CONTACT,
WASH WITH SOAP AND WATER.
WARNING: HOT OIL MAY CAUSE BURNS TO EYES AND SKIN. PUT ON SPLASH GOGGLES AND
INSULATED GLOVES, AND OTHER PROTECTIVE GEAR. IN CASE OF EYE CONTACT,
FLUSH WITH WATER FOR 15 MINUTES AND SEEK MEDICAL ATTENTION. IN CASE OF
SKIN CONTACT, WASH WITH SOAP AND WATER.
WARNING: ENGINE OIL IS HAZARDOUS AND MAY CAUSE INJURY TO SKIN AND EYES. PUT ON
PERSONNEL PROTECTIVE GEAR.
WARNING: USE THE CORRECT PERSONAL PROTECTION. HEATED PARTS WILL CAUSE BURNS.
WARNING: WHEN YOU USE COMPRESSED AIR TO CLEAN OR DRY PARTS, MAKE SURE THAT
THE PRESSURE IS NOT MORE THAN 30 PSI. DO NOT DIRECT THE AIRSTREAM AT
PERSONNEL OR LIGHT OBJECTS. PUT ON GOGGLES OR A FACE SHIELD TO
PROTECT YOUR EYES. IF YOU GET AN EYE INJURY, GET MEDICAL ATTENTION.
WARNING: LUBRICANTS ARE TOXIC AND FLAMMABLE. DO NOT BREATHE VAPORS. BEFORE
YOU USE, READ THE MATERIAL SAFETY DATA SHEET (MSDS) FROM THE
MANUFACTURER OR SUPPLIER. USE IN A WELL VENTILATED AREA FREE FROM
SPARKS. WEAR PROTECTIVE GEAR. IN CASE OF EYE CONTACT, FLUSH WITH
WATER FOR 15 MINUTES AND SEEK MEDICAL ATTENTION. IN CASE OF SKIN
CONTACT, WASH WITH SOAP AND WATER.
WARNING: USE THE CORRECT PERSONAL PROTECTION. POLISHING WILL CAUSE LOOSE
PARTICLES THAT CAN GET IN YOUR EYES.
v
© March 2005 Superior Air Parts Inc.
General Information
To Next Page
Loading...
Need help?
General
