Takeuchi TL10 - Page 11

0-9
Replacing the hydraulic oil return filter ... 5-45
Replacing the pilot line filter ................ 5-45
Replacing the travel motor gear oil ..... 5-45
Replacing the fuel filters ..................... 5-45
Adjusting or replacing the bucket
stoppers (bolts/nuts)
.......................... 5-46
Every 1000 hours .................................. 5-49
Cleaning the engine cooling system ... 5-49
Replacing the hydraulic oil and cleaning
the suction strainer ............................ 5-51
Inspecting and adjusting the engine
valve clearance
.................................. 5-53
Every 1500 hours .................................. 5-54
Replacing the oil separator element ... 5-54
Inspecting the injector tip ................... 5-54
Inspecting the EGR cooler ................. 5-54
Inspecting the PCV valve (TL10/TL12) .. 5-54
Every 3000 hours .................................. 5-55
Inspecting the turbocharger ............... 5-55
Inspecting the EGR system ................ 5-55
Every 6000 hours .................................. 5-55
Cleaning the DPF ............................... 5-55
When required ....................................... 5-56
Replacing the bucket or attachment .. 5-56
Inspecting and replenishing the
windshield washer fluid
...................... 5-58
Lubricating the levers ......................... 5-58
Inspecting the rubber tracks .............. 5-59
Every year .............................................. 5-60
Replacing the receiver drier ................5-60
Tilting up the canopy (cab) ..................... 5-61
Maintenance during extended storage
period
.................................................... 5-62
Troubleshooting ...............................6-1
Symptoms that are not malfunctions .......6-2
If the engine overheats ............................. 6-3
If the battery goes dead ........................... 6-4
If a fuse blows ......................................... 6-6
Inspecting and replacing the fuse .........6-6
Inspecting the fusible link ..................... 6-8
Restarting after adding fuel ...................... 6-9
Bleeding air from the fuel system .........6-9
If a warning lamp flashes ....................... 6-10
Vehicle error code list ............................. 6-12
Engine error code list ............................. 6-13
Other symptoms .................................... 6-16
Lowering the lift arms to the ground....... 6-18
Towing ................................................... 6-19
If the cab or canopy is damaged ........... 6-20
Exhaust gas control system error ........... 6-21
Error code list ....................................6-21
NOx control diagnostic system (NCD) ... 6-22
Particulate control diagnostic system
(PCD) ................................................ 6-22
Limiting the engine output .................. 6-23
Specifications ..................................7-1
Basic Specifications ................................. 7-2
Machine dimensions ................................ 7-6
Operating ranges ................................... 7-10
Options ............................................8-1
General precautions ................................8-2
Safety precautions ............................... 8-2
Cautions when installing attachments .. 8-2
Cautions when operating attachments ...8-3
Hydraulic quick-hitch ............................... 8-4
Replacing the Bucket or Attachment .. 8-4
Quick-Couplers ....................................... 8-6
4-Port quick-coupler (TL10/TL12) ............ 8-7
Selecting a lever pattern .......................... 8-9
Switching the lever pattern .................. 8-9
Seat (with a switch function) .................. 8-10
Optional equipment mass ...................... 8-11
Takeuchi Fleet Management .................. 8-12
Installing optional equipment on the rear
of the machine
....................................... 8-13