Toro DH 220 User Manual (English)

Questions and Answers:

M
Michael BryanAug 19, 2025
Why won't my Toro DH 220 engine start, starts hard, or fails to keep running?
- A
  Adam CantrellAug 19, 2025
  Several factors can cause this issue. Make sure you are sitting on the seat and that the fuel tank isn't empty. Check if the air cleaner is dirty and either clean or replace it. Ensure the spark plug wire is securely connected to the spark plug, and that the spark plug isn't damaged or incorrectly gapped—replace it if needed. Also, ensure the choke is closing properly by adjusting the throttle cable. Check the fuel filter for dirt and replace if needed. Finally, check that the fuel shut-off valve is open.
E
Elizabeth FinleyAug 21, 2025
What to do if my Toro DH 220 starter does not crank?
- M
  Melissa PenaAug 21, 2025
  If the starter doesn't crank, several things could be the cause. First, ensure the blade control (PTO) knob is in the Disengaged position. Next, make sure the parking brake is set. If those aren't the issue, the battery may be dead, so try charging it. Also, check the electrical connections to ensure they are clean and tight. Finally, inspect the fuse and replace it if it's blown.
K
Karen LevyAug 23, 2025
Why won't my Toro DH 220 engine start?
- J
  Jeffery JonesAug 25, 2025
  If your Toro Lawn Mower engine won't start, starts hard, or fails to keep running, try the following: Ensure you are sitting on the seat, fill the fuel tank with gasoline, clean or replace the air cleaner element, install the wire on the spark plug, install a new, correctly-gapped spark plug, adjust the throttle cable, replace the fuel filter, adjust the carburetor idle speed and idle mixture, and open the fuel shut-off valve. If the issue persists, contact an Authorized Service Dealer.
J
Jennifer RothAug 26, 2025
Why does my Toro DH 220 Lawn Mower engine loses power?
- T
  Tammy BlackAug 26, 2025
  Several factors can cause the engine to lose power. First, reduce your ground speed if the engine load is excessive. Inspect the air cleaner and clean it if it's dirty. Check the oil level in the crankcase and add oil if it's low. Remove any obstructions from the cooling fins and air passages under the engine blower housing. Replace the spark plug if it's pitted, fouled, or incorrectly gapped. Clean or replace the fuel cap if the vent hole is plugged. Lastly, replace the fuel filter if it's dirty.
J
Jeremy FoxAug 28, 2025
Why is the cutting height uneven on my Toro DH 220?
- D
  Deborah ChandlerAug 28, 2025
  Uneven cutting height can occur for several reasons. Ensure the tire pressure is correct. Adjust the height adjustment cable rod assembly to level the mower. Clean the underside of the mower if it's dirty. Lastly, tighten the blade mounting screws.
C
Charles SpencerAug 30, 2025
Why does my Toro Lawn Mower engine lose power?
- K
  Kimberly GonzalesAug 30, 2025
  If your Toro Lawn Mower engine loses power, try the following: Reduce your ground speed, clean the air cleaner element, add oil to the crankcase, remove any obstructions from the cooling fins and air passages, install a new, correctly-gapped spark plug, clean or replace the fuel cap, and replace the fuel filter. If the issue persists, contact an Authorized Service Dealer.
J
James WarrenSep 1, 2025
How to fix the uneven cutting height on my Toro Lawn Mower?
- J
  Jacob NicholsSep 1, 2025
  If the cutting height of your Toro Lawn Mower is uneven, set the tire pressure, adjust the height adjustment cable rod assembly, clean the underside of the mower, tighten the blade mounting screws and adjust the blade drive belt.
A
Amber SwansonSep 3, 2025
Why is my Toro DH 220 Lawn Mower engine overheats?
- M
  mlopezSep 3, 2025
  Your Toro Lawn Mower engine may overheat due to several reasons. If the engine load is excessive, reduce the ground speed. Check the oil level in the crankcase and add engine oil if it's low. Also, inspect the cooling fins and air passages under the engine blower housing for any obstructions and remove them.
S
susanjonesSep 5, 2025
What to do if my Toro DH 220 Lawn Mower has abnormal vibration?
- W
  williamyoungSep 6, 2025
  Abnormal vibration can stem from several issues. Start by inspecting the blades; if they are bent or unbalanced, replace them. Check and tighten the blade mounting screws. Also, tighten the engine mounting bolts. Finally, tighten any loose engine pulley, idler pulley, or blade pulley.
R
Richard GonzalezSep 7, 2025
Why is my Toro DH 220 engine overheating?
- A
  adamthomasSep 8, 2025
  If your Toro Lawn Mower engine overheats, try reducing the ground speed, adding oil to the crankcase, and removing any obstructions from the cooling fins and air passages.

Toro DH 220 Specifications

General

Brand	Toro
Model	DH 220
Category	Lawn Mower
Language	English

Summary

Operator's Manual Introduction

Manual Overview and Purpose

Provides an overview of the lawn mower's intended use and manual structure.

Model and Serial Number Identification

Guides users to locate the model and serial numbers for service and registration.

Comprehensive Safety Guidelines

Safe Operation Practices for Riding Mowers

Essential safety rules for operating the riding lawn mower.

Fuel Handling and Storage Safety

Critical safety information for handling and storing flammable fuel.

Pre-Operation Safety Checks

Pre-operation checks and safety considerations before starting the machine.

Maintenance and Storage Safety Precautions

Safety procedures related to machine maintenance and storage.

Safe Hauling and Transportation

Guidelines for safely loading and transporting the lawn mower.

Noise and Vibration Safety Information

Details on sound pressure, sound power, and vibration levels for operator safety.

Slope Safety and Component Identification

Slope Indicator and Safe Operation Limits

Explains how to use the slope indicator and maximum safe operating angles.

Manufacturer's Mark and Blade Identification

Identifies the blade as a part from the original manufacturer.

Understanding Safety and Instructional Decals

Explains the meaning and importance of various safety and instructional decals on the machine.

Instrument Panel Indicators and Safety Labels

Describes indicators on the instrument panel and other key safety labels.

Machine Overview and Technical Specifications

Machine Controls and Operation Interface

Identifies and explains the function of each control on the machine.

Key Machine Specifications

Lists key technical specifications of the lawn tractor.

Operating the Lawn Tractor

Fueling the Lawn Tractor

Instructions for safely filling the fuel tank with the correct gasoline.

Engine Oil and Parking Brake Procedures

Procedures for checking engine oil level and using the parking brake.

Seat Adjustment and Headlight Operation

How to adjust the seat and operate the headlights.

Blade Engagement and PTO Control

How to engage and disengage the Power Take-Off (PTO) for the mower blades.

Setting Cutting Height and Starting Engine

Steps for setting cutting height and starting the engine.

Safety Interlock System Operation

Explains the safety interlock system and its functions.

Reverse Mowing and KeyChoice Switch

How to enable reverse mowing using the KeyChoice switch.

Testing Safety Interlock System Functionality

Procedures to verify the proper function of safety interlock switches.

Manual Pushing and Driving the Machine

How to manually push the machine and drive it forward/backward.

Grass Clipping Management and Disposal

Using the recycle-on-demand feature and emptying the grass collector.

Rear-Discharging Grass Clippings

How to cut grass without using the grass collector.

Using the Optional Towing Hitch

Instructions for attaching and using the optional towing hitch.

Effective Operating Tips for Mowing

Tips for optimal cutting, grass management, and blade care.

Routine Maintenance Procedures

Recommended Maintenance Schedule

Outlines required maintenance tasks and their service intervals.

Lubrication and Greasing Procedures

Guidance on greasing and lubricating the machine's components.

Engine Air Filter Servicing and Replacement

How to service or replace the engine's air cleaner element.

Engine Oil and Filter Change Procedures

Step-by-step guide to change the engine oil and oil filter.

Spark Plug Service and Installation

How to check, service, and install the spark plug.

Fuel System Servicing

Draining the Fuel Tank Safely

Procedures for draining the fuel tank for safety and storage.

Replacing the Fuel Filter

Steps to replace the fuel filter on the machine.

Electrical System Servicing

Headlight Bulb Replacement Guide

Instructions for replacing burnt-out headlight bulbs.

Fuse Replacement and Battery Care

How to replace fuses and general battery care instructions.

Battery Installation and Electrolyte Level Management

Steps for installing the battery and checking its electrolyte level.

Battery Charging and Water Addition

Procedure for safely adding distilled water and charging battery cells.

Drive System and Collector Maintenance

Tire Pressure and Brake System Maintenance

How to check tire pressure and service the brake system.

Brake Adjustment and Grass Collector Servicing

Procedures for checking, adjusting brakes, and servicing the grass collector.

Mower Deck Servicing

Cleaning the Grass Collector and Discharge Tunnel

How to clean the grass collector bag and discharge tunnel.

Blade Removal, Sharpening, and Installation

Steps to remove, sharpen, balance, and install mower blades.

Mower Deck Removal and Reattachment

Procedures for detaching and reattaching the mower deck from the tractor.

Machine Storage Guidelines

Preparing the Lawn Tractor for Storage

Steps to prepare the lawn mower for long-term storage.

Final Storage Checks and Battery Care

Final steps for storage, including spark plug, battery, and general checks.

Troubleshooting and System Schematics

Engine Starting and Running Problem Diagnosis

Common problems with engine starting, overheating, and power loss.

Machine Operation and Cutting Issue Resolution

Solutions for vibration, blades not rotating, and uneven cutting height.

Control Module Wiring Diagram

Provides a wiring diagram for the machine's control module.

Related product manuals

Toro Groundsmaster 220-D

352 pages

Toro Reelmaster 3100-D

385 pages

Toro Reelmaster 5510-D

128 pages

Toro Reelmaster 5500-D

44 pages

Toro Reelmaster 5410-D

92 pages

Toro Reelmaster 3240-D

87 pages

Toro Reelmaster 5100-D

38 pages

Toro DH 220 User Manual

Table of Contents

Questions and Answers:

Toro DH 220 Specifications

Summary

Operator's Manual Introduction

Manual Overview and Purpose

Model and Serial Number Identification

Comprehensive Safety Guidelines

Safe Operation Practices for Riding Mowers

Fuel Handling and Storage Safety

Pre-Operation Safety Checks

Maintenance and Storage Safety Precautions

Safe Hauling and Transportation

Noise and Vibration Safety Information

Slope Safety and Component Identification

Slope Indicator and Safe Operation Limits

Manufacturer's Mark and Blade Identification

Understanding Safety and Instructional Decals

Instrument Panel Indicators and Safety Labels

Machine Overview and Technical Specifications

Machine Controls and Operation Interface

Key Machine Specifications

Operating the Lawn Tractor

Fueling the Lawn Tractor

Engine Oil and Parking Brake Procedures

Seat Adjustment and Headlight Operation

Blade Engagement and PTO Control

Setting Cutting Height and Starting Engine

Safety Interlock System Operation

Reverse Mowing and KeyChoice Switch

Testing Safety Interlock System Functionality

Manual Pushing and Driving the Machine

Grass Clipping Management and Disposal

Rear-Discharging Grass Clippings

Using the Optional Towing Hitch

Effective Operating Tips for Mowing

Routine Maintenance Procedures

Recommended Maintenance Schedule

Lubrication and Greasing Procedures

Engine Air Filter Servicing and Replacement

Engine Oil and Filter Change Procedures

Spark Plug Service and Installation

Fuel System Servicing

Draining the Fuel Tank Safely

Replacing the Fuel Filter

Electrical System Servicing

Headlight Bulb Replacement Guide

Fuse Replacement and Battery Care

Battery Installation and Electrolyte Level Management

Battery Charging and Water Addition

Drive System and Collector Maintenance

Tire Pressure and Brake System Maintenance

Brake Adjustment and Grass Collector Servicing

Mower Deck Servicing

Cleaning the Grass Collector and Discharge Tunnel

Blade Removal, Sharpening, and Installation

Mower Deck Removal and Reattachment

Machine Storage Guidelines

Preparing the Lawn Tractor for Storage

Final Storage Checks and Battery Care

Troubleshooting and System Schematics

Engine Starting and Running Problem Diagnosis

Machine Operation and Cutting Issue Resolution

Control Module Wiring Diagram

Related product manuals