4 CLCH-SVX013B-EN
Table of Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Nameplate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
General Information . . . . . . . . . . . . . . . . . . . . . 7
Operating Environment . . . . . . . . . . . . . . . . 7
Unit Description . . . . . . . . . . . . . . . . . . . . . . . 7
Components . . . . . . . . . . . . . . . . . . . . . . . . 7
Factory-Mounted Controls . . . . . . . . . . . . . 7
Pre-Packaged Solutions for Controls . . . . 7
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Pre-Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Receiving and Handling . . . . . . . . . . . . . . . . 9
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Packaging/Shipping . . . . . . . . . . . . . . . . . . 9
Identification . . . . . . . . . . . . . . . . . . . . . . . . 9
Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Receiving Checklist . . . . . . . . . . . . . . . . . . 9
Jobsite Storage . . . . . . . . . . . . . . . . . . . . . . . 9
Outdoor Storage . . . . . . . . . . . . . . . . . . . . . 9
Long-Term Storage . . . . . . . . . . . . . . . . . 10
Site Preparation . . . . . . . . . . . . . . . . . . . . . . 10
Roof Curb Installation Checklist . . . . . . . 10
Dimensions and Weights . . . . . . . . . . . . . . . . 12
Service Clearance Recommendations . . . 12
Fans/Motors . . . . . . . . . . . . . . . . . . . . . . . . . 13
VFD Weights . . . . . . . . . . . . . . . . . . . . . . . 13
Motor Weights . . . . . . . . . . . . . . . . . . . . . 13
Installation - Mechanical . . . . . . . . . . . . . . . . 14
Lifting and Rigging . . . . . . . . . . . . . . . . . . . 14
Remove Shipping Tie-Downs . . . . . . . . . 14
General Lifting Considerations . . . . . . . . 14
Lifting Hoods and Pipe Cabinets . . . . . . . 15
Forklifting Considerations . . . . . . . . . . . . 15
Unit Placement and Assembly . . . . . . . . . . 16
Removing the Shipping Skid . . . . . . . . . . 17
Ceiling Suspension . . . . . . . . . . . . . . . . . 17
Shipping Gussets . . . . . . . . . . . . . . . . . . . 18
Section-to-Section Assembly . . . . . . . . . 18
Pipe Cabinet Installation . . . . . . . . . . . . . 22
Hood Installation . . . . . . . . . . . . . . . . . . . .24
Stacked Outdoor Unit Assembly . . . . . . .25
External Raceway Assembly . . . . . . . . . . .30
Seismic Application Requirements . . . . . . .31
Single Level Design . . . . . . . . . . . . . . . . . .31
Stacked Design . . . . . . . . . . . . . . . . . . . . . .32
Ceiling Suspended Units . . . . . . . . . . . . . .33
Anchoring . . . . . . . . . . . . . . . . . . . . . . . . . .33
Pipe Cabinet Installation . . . . . . . . . . . . . .34
Component Installation . . . . . . . . . . . . . . . . . .36
Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Damper Torque Requirements . . . . . . . . .36
Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Fan Isolation . . . . . . . . . . . . . . . . . . . . . . . .36
Adjusting the Isolators . . . . . . . . . . . . . . . .36
Motor Removal Rail . . . . . . . . . . . . . . . . . .37
Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37
Final Filter Section . . . . . . . . . . . . . . . . . . .37
Pre-Filter Section . . . . . . . . . . . . . . . . . . . .37
Filter Installation . . . . . . . . . . . . . . . . . . . . .37
Duct Connections . . . . . . . . . . . . . . . . . . . . . .38
Fan Discharge Connections . . . . . . . . . . . .38
Damper Connections . . . . . . . . . . . . . . . . .38
Bottom Opening Duct Installation . . . . . .38
Discharge Plenum Connections . . . . . . . .39
Bell Mouth Discharge Connections . . . . .40
Traq Damper Connections . . . . . . . . . . . .40
Other Connections . . . . . . . . . . . . . . . . . . .41
Piping and Connections . . . . . . . . . . . . . . . . . .42
General Recommendations . . . . . . . . . . . . .42
Drain Pan Trapping . . . . . . . . . . . . . . . . . . . .42
Steam Coil Piping . . . . . . . . . . . . . . . . . . . . .43
Water Coil Piping . . . . . . . . . . . . . . . . . . . . . .45
Refrigerant Coil Piping . . . . . . . . . . . . . . . . .46
Liquid Lines . . . . . . . . . . . . . . . . . . . . . . . . . .47
Suction Lines . . . . . . . . . . . . . . . . . . . . . . . . .48
Expansion Valves . . . . . . . . . . . . . . . . . . . . . .48
Hot Gas Bypass . . . . . . . . . . . . . . . . . . . . . . .48