Name: TriangleTube PSRKIT25
Brand: TriangleTube
Rating: 4 (1 reviews)

To Next Page

To Previous Page

Boiler Piping

Fig. 8 : Near Boiler Piping - Closed Type Expansion Tank

Fig. 7: Near Boiler Piping - Diaphragm Expansion Tank

Note: Pitch horizontal pip-

ing upwards (1” of pitch

per 5 ft of piping) towards

expansion tank.

Default Chapter2
- Table of Contents2
Product and Safety Information7
- Definitions7
- Product and Safety Information8
Section I - Pre-Installation Items9
- Code Compliance9
- Determining Product Location9
- Boiler Replacement9
- Recommended Clearances9
- Residential Garage Installations10
- Boiler Freeze Protection Feature10
Section II - Combustion Air and Venting11
- Combustion Air Contamination11
- Ventilation and Combustion Air Requirements - Direct Vent12
- Ventilation and Combustion Air Requirements - Category IV12
- Methods of Accessing Combustion Air into a Space - Category IV13
- Combustion Air and Vent Piping15
- Removal of an Existing Boiler from a Common Vent System16
- Commonwealth of Massachusetts Installation17
Section III - Unit Preparations18
- Handling Instructions18
- Wall Mounting Installation18
- Wall Mounting Guidelines18
- Wall Bracket Installation - Stud Walls19
- Wall Bracket Installation - Solid Walls19
- Boiler Mounting19
Section IV - Boiler Piping20
- General Piping Requirements20
- Pressure Relief Valve20
- Low Water Cutoff Device20
- Boiler Piping21
- Additional Limit Control22
- Backflow Preventer22
- Boiler System Piping Applications22
- Expansion Tank and Makeup Water22
  - Diaphragm Expansion Tank23
  - Closed-Type Expansion Tank23
- Circulator23
- Sizing Primary Piping23
- Domestic Hot Water System Piping23
- System Piping - Zone Circulators23
- System Piping - Zone Valves23
- Piping Component Legend24
- Near Boiler Piping Diagrams25
- System Piping - through Boiler26
- System Piping - Radiant Heating26
- System Piping - Special Applications26
- System Piping - Multiple Units Installation26
- System Piping Diagrams27
Section V - Installing Vent / Combustion Air & Condensate Drain30
- Installing Vent and Combustion Air30
- Installing Condensate Drain Assembly30
Section VI - Gas Piping32
- Gas Supply Piping Connection32
- Natural Gas33
  - Pipe Sizing -Natural Gas33
  - Natural Gas Supply Pressure Requirements33
- Propane Gas34
Section VII - Internal Wiring36
- General Requirements36
- Internal Factory Wiring Diagram37
Section VIII - External Wiring38
- Installation Compliance38
- Line Voltage Connections38
- Circulator Wiring38
- Alarm Wiring39
- Low Voltage Connections39
- Thermostat Wiring39
- Outdoor Sensor Wiring40
- Domestic Hot Water Wiring40
- Additional Boiler Limits40
- External Modulation Control40
- System Sensor Wiring40
- Cascade Wiring41
- Modbus Wiring41
- Zone Valve Wiring42
- External Wiring42
- Zone Circulator Wiring43
- System Piping Wiring Diagrams44
Section IX - Trimax Operation46
- Trimax User Interface46
- Trimax Navigation47
- Trimax Menu Structure48
- Home Screen49
- Status Line Messages50
- Main Menu51
- EZ Setup Menu52
- Heating EZ Setup52
- Domestic Hot Water EZ Setup54
- EZ Setup Reset55
- Display EZ Setup55
- CH/DHW Operation56
- Boiler Information56
- Information Items57
- Lockout History58
- Lockout Screen59
- Manual Reset Hard Lockouts60
- Automatic Reset Soft Lockouts61
Section X - Start-Up Preparation62
- Check Boiler System Water Chemistry62
- Flush Boiler System and Domestic System to Remove Sediment62
- Check and Test Antifreeze62
- Use of Antifreeze in the Boiler System63
- Filling the Boiler System63
- Check Low Water Cut-Off Device63
- Check for Gas Leaks64
- Check Thermostat Circuit64
- Inspection of Condensate Drain Assembly64
Section XI- Start-Up Procedures65
- Final Checks before Start-Up65
- PRESTIGE solo Start-Up65
- If PRESTIGE solo Does Not Start Correctly65
- Check the PRESTIGE solo and System65
- Operating Instructions68
Section XII - Outdoor Reset Control69
- Mounting the Outdoor Sensor69
- Wiring the Sensor69
Section XIII - External Modulating Control70
- Wiring the Modulating Controller70
- Trimax Adjustment70
- Programming of External Modulating Control70
- Factory Trimax Settings71
- External Modulating Control71
Section XIV - Check-Out Procedures72
- Check-Out Procedures72
Section XV - Installation Record73
- Installation Record73
Sections XVI - Maintenance Schedule74
- Service Technician - General74
- Owner Maintenance74
SECTION XVII- Maintenance Procedures75
- Maintenance Procedures75
Replacement Parts81
- Replacement Parts89
Product Specifications90
- Specifications91

TriangleTube PSRKIT25 Installation & Maintenance Manual

Table of Contents

Other manuals for TriangleTube PSRKIT25

Questions and Answers:

TriangleTube PSRKIT25 Specifications

Related product manuals

Brand	TriangleTube
Model	PSRKIT25
Category	Boiler
Language	English