Victaulic FireLock NXT 776 Series User Manual

TABLEOFCONTENTS
Hazard Identification ......................................1
Installer Safety Instructions .................................2
General ..............................................2
Maintenance and Testing .................................2
Introduction .............................................3
Trim Dimensions .........................................3
Exploded View Drawing – Trim Components (Domestic Trim) .........4
Exploded View Drawing – Trim Components (Domestic Trim).........5
Exploded View Drawing – Trim Components (Domestic Trim) .........6
Exploded View Drawing – Trim Components (European Trim)........7
Exploded View Drawing – Trim Components (European Trim)........8
Exploded View Drawing – Trim Components (European Trim)........9
Exploded View Drawing – Internal Valve Components.............10
Section View Drawing and Description –
Series 776 Low-Pressure Actuator .......................11
Air Supply Requirements ..................................12
Compressor Sizing .....................................12
Base or Riser-Mounted Air Compressors ....................12
Shop Air or Tank-Mounted Air Compressors..................12
Victaulic Series 757 Regulated Air Maintenance
Trim Assembly (AMTA) Option ..........................12
Victaulic Series 757P Air Maintenance Trim Assembly
(AMTA) with Pressure Switch Option .....................13
Settings for Air Supervisory Pressure Switches and
Alarm Pressure Switches ..............................13
Important Installation Information ...........................13
Valve/Trim Installation ....................................14
Compression Fitting and Tube Installation ...................14
Hydrostatic Testing ......................................14
Wet Pilot Line Charts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Placing the System in Service ..............................18
External Inspection ......................................23
Weekly Inspection .....................................23
Monthly Inspection ....................................23
Required Tests..........................................24
Main Drain Test .......................................24
Water Flow Alarm Test ..................................25
Water Level and Low Air Alarm Tests .......................27
Required Operational (Trip) Tests............................30
Partial Operational (Trip) Test.............................30
Full Operational (Trip) Test ...............................32
Required Internal Inspection ...............................34
Maintenance ...........................................37
Removing and Replacing the Clapper Seal...................37
Removing and Replacing the Clapper Assembly...............39
Installing the Cover Plate Gasket and Cover Plate..............41
Removing and Replacing the Diaphragm Assembly ............42
Replacing the Strainer Screen for
Series 776 Low-Pressure Actuators . . . . . . . . . . . . . . . . . . . . . . 43
Troubleshooting – Series 776 Low-Pressure Actuator .............44
Troubleshooting – Series 753-E Solenoid Valve .................44
Troubleshooting – System .................................44
HAZARD IDENTIFICATION
Definitions for identifying the various hazard levels are
provided below. When you see this symbol, be alert to the
possibility of personal injury. Carefully read and fully
u nderstand the message that follows.
WARNING
Theuseoftheword“WARNING”identifiesthepresenceof•
hazardsorunsafepracticesthatcouldresultindeathorseri-
ouspersonalinjuryifinstructions,includingrecommended
precautions,arenotfollowed.
CAUTION
Theuseoftheword“CAUTION”identifiespossiblehazardsor•
unsafepracticesthatcouldresultinpersonalinjuryandproduct
orpropertydamageifinstructions,includingrecommendedpre-
cautions,arenotfollowed.
NOTICE
Theuseoftheword“NOTICE”identifiesspecialinstructions•
thatareimportantbutnotrelatedtohazards.
I-769D_1
FireLockNXT™DelugeValve
SERIES 769
I-769DINSTALLATION,MAINTENANCE,ANDTESTINGMANUAL
www.victaulic.com
VICTAULIC IS A REGISTERED TRADEMARK OF VICTAULIC COMPANY. © 2007 VICTAULIC COMPANY. ALL RIGHTS RESERVED. PRINTED IN THE USA.
REV_D

Victaulic FireLock NXT 776 Series Specifications

General

Brand	Victaulic
Model	FireLock NXT 776 Series
Category	Control Unit
Language	English