4
CONTENTS
PAGE
SECTION I INSTALLATION AND SETUP……………………………………………………………………………………….
A. VISUAL INSPECTION OF THE HEATING SYSTEM…………………………………………………………………..
B. INSPECTION OF FLUE PIPE AND CHIMNEY…………………………………………………………………………
C. INSPECTION OF HEATING APPLIANCE……………………………………………………………………………..
D. FLUE PIPE, DRAFT HOOD, AND BAROMETRIC DAMPER………………………………………………………..
E. PREPARATION OF COMBUSTION CHAMBER………………………………………………………………………
F. SIZING OF COMBUSTION CHAMBER…………………………………………………………………………………
G. BURNER INSTALLATION….…………………………………………………………………………………………….
H. INSTALLATION OF MOUNTING FLANGE…………………………………………………………………………….
I. DETERMINE ORIFICE SIZE AND RATE………………………………………………………………………………
J. INSPECTION AND SIZING OF GAS PIPING………………………………………………………………………….
K. TESTING PIPING FOR LEAKS………………………………………………………………………………………….
L. ELECTRICAL WIRING OF BURNER……………………………………………………………………………………
M. INSPECTION OF LIMIT CONTROL SWITCHES………………………………………………………………………
N. INSTALLATION OF THERMOSTAT…………………………………………………………………………………….
SECTION II INITIAL START UP……………………………………………………………………………………………………
A. OPERATION OF BURNER (DIRECT IGNITION)………………………………………………………………………
B. OPERATION OF BURNER (ELECTRONIC PILOT)…………………………………………………………………..
C. OPERATION OF BURNER (STANDING PILOT)………………………………………………………………………
D. COMBUSTION ADJUSTMENT OF BURNER………………………………………………………………………….
E. FINAL INSTALLATION INSTRUCTIONS……………………………………………………………………………….
SECTION III GAS CONVERSION……………………………………………………………………………………………………
A. NATURAL GAS AND LP CONVERSION INSTRUCTIONS………………………………………………………….
SECTION IV CONSUMER INSTRUCTIONS………..……..…………………………………………………………………….
A. GENERAL INSTRUCTIONS FOR SERVICING BURNER……………………………………………………………
SECTION V SERVICE AND TROUBLESHOOTING……………………………………………………………………………
A. NORMAL OPERATION CHECK OF BURNER (DIRECT IGNITION)………………………………………………..
B. NORMAL OPERATION CHECK OF BURNER (ELECTRONIC PILOT).……………………………………………
C. TROUBLESHOOTING GUIDE DIRECTION IGNITION……………………………………………………………….
D. TROUBLESHOOTING GUIDE ELECTRONIC PILOT (S8600 CONTROL)…………………………………………
To Next Page
Loading...
