Welbilt MERRYCHEF conneX User Manual

4 Accessing the easyTouch
®
2.0
Back to contents >
Merrychef conneX
®
service and repair manual 35
IMPORTANT
Cool down the oven before
4.3 Cleaning procedures
Cool down the oven
You will need
PPE:
 heat proof gloves
 protective rubber
gloves
 eye protection
Cleaning materials:
 non-abrasive nylon scrub pad
 cleaning cloths
 Merrychef oven cleaner (or
Merrychef approved cleaning
chemicals)
 Merrychef oven protector
1. Press the clean icon from
the main menu (full serve
mode) or the on/off button
on any screen.
2. Place a pan of ice into the
oven to speed up the cool
down process or leave the
door slightly open. Press the
green tick to continue at each
stage.
3. Wait for temperature to
reduce to 50°C or 122°F. This
can take up to approximately
20 mins.
4. Once the cooling process is
complete, remove the cook
plate and pan of water if used.
Then follow the screen
instructions - the oven is now
ready for cleaning.
5. Use a dry clean brush to
remove any food particles
from between the cavity floor
and the inside of the front
door.
6. Spray Merrychef approved
cleaner onto a sponge and
wipe onto the sides of the
inside of the oven, the back,
the base and the oven door.
Avoid the roof and door seal.
7. leave to soak for 5 – 10
minutes for the cleaner
to work and clean the
cook plate.
8. Clean the cavity with a non-
abrasive sponge. Wipe off the
cleaner with a wet cloth,
ensuring all cleaning
chemicals and debris are
removed. The cavity roof and
door seal can also be gently
wiped if necessary, to remove
food debris. Dry with a clean
dry cloth.
9. If instructed spray
Merrychef approved protector
onto a clean cloth and wipe
cavity side, back and oven
door. Refit the cook plate.
10. Remove the air filter and
wipe it clean or wash in soapy
water. Dry and replace.
11. After the oven
switches off. Wipe the
outside of the oven with a
clean sanitised cloth.
12. If instructed enter the
cleaners’ initials. The oven
will switch off on completion.
Clean the cold oven
Wear PPE
Pan and water may be hot.
Use heat proof gloves.
Do not leave the pan of
water in the oven overnight.
Do not spray directly into the
cavity. Avoid the roof and door seal.
WARNING: Do not use the oven without a clean
filter in place. Do not use caustic cleaners in the
oven cavity as they cause permanent damage
to the catalytic converters. Do not use tools,
sharp implements, or harsh abrasives on any
part of the oven.

Welbilt MERRYCHEF conneX Specifications

General

Brand	Welbilt
Model	MERRYCHEF conneX
Category	Commercial Food Equipment
Language	English