Yanmar 3YM30E - Page 4

TABLE OF CONTENTS
YM Series Operation Manual
BEFORE YOU OPERATE .............................................. 25
INTRODUCTION ...................................................... 25
SAFETY PRECAUTIONS......................................... 25
DIESEL FUEL........................................................... 26
Diesel Fuel Specifications .................................. 26
Filling the Fuel Tank........................................... 29
Bleeding the Fuel System .................................. 30
ENGINE OIL ............................................................. 31
Engine Oil Specifications .................................. 31
Engine Oil Viscosity .......................................... 31
Checking the Engine Oil..................................... 32
Adding Engine Oil .............................................. 32
MARINE GEAR OR SAIL DRIVE OIL ...................... 33
Marine Gear Oil Specifications........................... 33
Sail Drive Oil Specifications- SD20 .................... 33
Checking Marine Gear Oil.................................. 33
Adding Marine Gear Oil...................................... 33
Checking and Adding Sail Drive Oil ................... 33
ENGINE COOLANT ................................................. 34
Engine Coolant Specifications ........................... 34
Coolant (Closed Cooling System) ...................... 34
Checking and Adding Coolant............................ 35
CRANKING THE ENGINE........................................ 37
ENGINE OPERATION .................................................... 39
INTRODUCTION ...................................................... 39
SAFETY PRECAUTIONS......................................... 39
STARTING THE ENGINE ........................................ 41
If the Engine Fails to Start.................................. 42
Starting at Low Temperatures............................ 42
After the Engine has Started .............................. 43
REMOTE CONTROL HANDLE OPERATION .......... 44
Acceleration and Deceleration ........................... 44
Shifting the Engine ............................................. 44
CAUTIONS DURING OPERATION.......................... 45
SHUTTING DOWN THE ENGINE ............................ 46
Normal Shutdown............................................... 46
Emergency Shutdown ........................................ 47
CHECKING THE ENGINE AFTER OPERATION..... 48
PERIODIC MAINTENANCE ........................................... 49
INTRODUCTION ...................................................... 49
SAFETY PRECAUTIONS......................................... 49
YM OPM_EN.book 2 ページ ２０１３年６月７日 金曜日 午前１１時１１分