ATS Pyro-Clean - Page 9

MAN - Pyrolytic Oven - REV: Original | B. Safety4
WARNING: To avoid electrical shock, this furnace must use a properly grounded electrical supply
of correct voltage and current handling capacity, and be disconnected from the power supply
prior to maintenance and servicing.
WARNING: To avoid personal injury do not use in Class I, II, or Ill locations as dened by the
National Electrical Code.
WARNING: Do not use in the presence of ammable or combustible materials; re or explosion
may result. This device contains components which may ignite such materials.
WARNING: Do not put sealed containers in oven.
WARNING: Refer servicing to qualied personnel.
WARNING: THIS PRODUCT CONTAINS REFRACTORY CERAMIC, REFRACTORY
CERAMIC FIBER OR FIBERGLASS (GLASS WOOL) INSULATION WHICH CAN PRODUCE
RESPIRABLE FIBERS AND DUST WHEN HANDLED. THESE FIBERS OR DUSTS CAN
CAUSE IRRITATION AND CAN AGGRAVATE PRE-EXISTING RES PIRATORY DISEASE.
REFRACTORY CERAM IC INSULATIONS MAY CONTAIN OR MAY FORM CRYSTALLINE
SILICA (CRYSTO BALITE) WHICH MAY CAUSE LUNG DAMAGE (SILICOSIS).
THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (!ARC) HAS CLASSIFIED
REFRACTORY CERAMIC FIBER AND FIBERGLASS AS {28) POSSIBLY CARCINOGENIC.
!ARC HAS CLASSIFIED CRYSTALLINE SILICA AS (2A) PROBABLY CARCINOGENIC.
The insulating materials are located in the door, the hearth collar, in the chamber of the product
or the top plate assembly. Tests performed by the manufacturer indicate that there is no
signicant risk of exposure to dust or respirable bers resulting from operation of this equipment
under normal conditions. However, there may be a risk of exposure to respirable dusts or
bers when repairing or maintaining the insulating materials, or when otherwise disturbing the
materials in a manner which causes release of dust or bers therefrom. Through the use of
proper handling procedures you can work safely with these insulating materials and minimize
any exposure.
Accordingly, before you repair or replace any insulating materials, or perform any other servicing
on this product which could disturb or cause exposure to dust from insulating materials, you
should consult the appropriate Material Safety Data Sheets (MSDS’s) for such products with
respect to proper handling and appropriate protective equipment. For additional MSDS’s, or
additional information concerning the handling of refractory ceramic products, please contact the
ATS Service Department at +1-724-283-1212.
WARNING: This warning is presented for compliance with California Proposition 65 and other
regulatory agencies and only applies to the insulation in this product. This product contains
refractory ceramic, refractory ceramic ber or ber glass insulation, which can produce respirable
dust or bers during disassembly. Dust or bers can cause irritation and can aggravate pre-
existing respiratory diseases. Refractory ceramic and refractory ceramic bers (after reaching
1000°C) contain crystalline silica, which can cause lung damage (silicosis). The International