HD-973P Series Multi-Level Parking Lift 73 P/N 5900076 — Rev. B3 — January 2024
Final Checklist
Make sure these things have been done before putting the Lift into service:
• Review the Installation Checklist to make sure all steps have been performed.
• Make sure the Power Unit is getting power from the power source.
• Check the Hydraulic Fluid reservoir on the Power Unit; it must be full of approved Hydraulic Fluid or
automatic transmission fluid. You can damage the motor by running it without enough
fluid.
• Check the Hydraulic System for leaks.
• Make sure all four Posts are properly anchored, shimmed, level, and stable.
• Make sure all Lifting Cables are properly seated in their Sheaves.
• Make sure all Safety Locks are operating normally.
• Make sure the backup Slack Safety Locks are not engaged.
• Make sure a copy of the Installation and Operation Manual is left with the Lift.
• If it has not been done already, perform an Operational Test of the Lift with a typical Vehicle. Refer
to Performing an Operational Test.
Operation
This section describes how to operate your Lift.
Safety Considerations
Do the following every time before you raise a Vehicle on your Lift:
• Check the Lift. Walk all the way around the Lift, checking for any missing, heavily worn, or
damaged parts. Do not operate the Lift if you find any issues; instead, take it out of service, then
contact your dealer, email support@bendpak.com, or call (800) 253-2363 option 7 then 4.
• Check the area. Keep the area around and under the Lift clean and free of obstructions;
anything that could cause a problem. Do not forget to check above the Lift. If you find an
obstruction, move it out of the way. If you find any other issues, resolve them before using the Lift.
Do not allow any people or animals within 30 feet of the Lift while it is in motion.
• Check the operators. Make sure everyone who is going to operate the Lift has been trained in
its use, has read the labels on the unit, and has read the manual. Only the operator at the Controls
should be within 10 feet of the Lift when it is in motion.
Do not allow children to operate the Lift. Do not allow anyone under the influence of drugs, alcohol,
or medication to operate the Lift. Do not allow any unauthorized personnel to operate the Lift.
• Check for safety. Make sure everyone who is going to be walking near the Lift is aware of its
presence and takes appropriate safety measures. Only put Vehicles on the Runways.
When raising a Vehicle, do not leave it until the Platform is engaged on a Safety Lock. When
lowering the Lift, do not leave it until it is on the ground.
• Check the vehicle. Never exceed the Lift’s weight rating. Do not allow people inside a Vehicle
you are going to raise. Double check you have everything you need out of the Vehicle before
raising the Lift. Make sure the Vehicle is not overbalanced on either end or either side.
To Next Page
Loading...
