Compool CP3000 - Plumbing Requirements

Compool Cp3000
3
PLUMBING REQUIREMENTS
Recommended Hydraulic Schematic
Plumb system in accordance with recommended hydraulic schematic, local codes and the following guidelines.
Bring all lines back to the equipment pad:
1. Spa should be at or above the level of the pool. If spa is attached to pool, provide a dam between the two bodies
of water and allow spa overflow into pool. If spa is not attached to pool, an overflow, sufficient in size to carry
full pump-flow, must be installed between spa and pool.
2. Plumb a 3-port Freedom Valve on the suction-side of the filter pump, so that center port of valve is connected to
the pump inlet. Connect spa suction to one side of Intake Valve, and pool suction to the other side.
3. Plumb a 3-port Freedom Valve on the output-side of the heater, so that return water will enter valve through the
center port. Connect spa return to one port, and pool return to the other.
4. A ¾” spa makeup line (incorporating a ¾” manual gate or ball valve and, for elevated spas, a ¾” check valve)
may be provided to bypass the pool return line. This will enable some of the pool water to cycle through the spa,
thus keeping it chemically balanced with the pool. The manual valve will allow the amount of bypass to be
adjusted.
5. If an optional Spa-Side Remote is to be used, install a 6” to 12” length of 1½” Sch. 40 pvc pipe above water level
in the spa wall so that the Spa-Side Remote will not be submerged. This can be done by positioning the top of
the 1 ½” pipe ½” below the coping. The pipe should be perpendicular to the spa wall and protrude beyond the
finished surface of the spa. It will be cut back at a later date. Outside the spa, reduce the pipe size down to ½” or
¾” conduit, and run to proposed Lx3000 Power Center location at equipment pad. Use sweep elbows for turns.
The Spa-Side Remote should not be installed until spa construction is complete.
;;
;;;
CP-3000
CONTROLLER
LX-3000
SERVICE CENTER
SOLAR
SENSOR
POOL
CLEANER
PUMP
CVA-24
CVA-24
HEATER
CVA-24
SOLAR
PUMP
VACUUM
RELIEF
WATER
SENSOR
SIMMER
FILTER
PUMP
FILTER
CVA-24
MAIN
DRAIN
HW-5B
SPA
ET
PUMP
BLOWER
WATERFALL
POOL
LIGHT
SPA-SIDE
REMOTE
AIR
INTAE
SPA
LIGHT
SPA POOL
Installation