Home
Edwards
Water Pump
iXL600
Edwards iXL600 User Manual
4
of 1
of 1 rating
70 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
© Edwards Limited 20
15. A
ll righ
ts reserved.
Page 9
Edwards
and the Edw
ard
s logo are trademarks of Edwards L
imited.
Technical data
A540-55-880 I
ssue D
2.3
Loading data
Figure 6 - Centre of gravity and levelling f
oot loads
T
able 4
- Loading
data (refer to Fi
gure
6)
Pump
Dimension to centre of gravity
L
oad at levelling foot position
AB
CD
E1234
U
n
i
t
s
m
mm
mm
mm
mm
m
k
g
k
g
k
g
k
g
iXL1000/
iXL600(N)
600
326
91
186
335
37
44
46
38
16
18
Table of Contents
Default Chapter
5
Table of Contents
5
Introduction
9
Scope and Definitions
9
Applications
10
The Ixl600 and Ixl1000 Systems
10
The Front Panel Controls
11
Front View of Pumping System
11
The Controls/Connectors on the Rear of the Pump
12
Priority of Control
13
Green Mode
13
Technical Data
15
General Technical Data
15
Performance Data
16
Continuous Operating Zones
16
Loading Data
17
Centre of Gravity and Levelling Foot Loads
17
Nitrogen Purge Data
18
Electrical Data
18
Cooling Water Data
20
Tracer Gas Analysis
22
Installation
23
Locate the Dry Pumping System
24
Seismic Brackets Fitting
24
Seismic Bracket Front and Side Attachments with Dimensions
25
Lubrication
26
Connect the Dry Pumping System to the Vacuum/Exhaust System
26
Connect to the Factory Extraction System (Optional)
27
Connect the Nitrogen Supply
27
Connecting the Pump Inlet
27
Flammable/Pyrophoric Materials
28
Gas Purges
28
Leak Test the System
28
Electrical Supply
29
Mains Supply Cable Connection
30
High and Low Voltage Coding Pin Arrangement
30
Mains Input Supply Connector
31
Electrical Connector Locking Mechanism
32
Method for Connecting Phase Wires
32
Protective Earth (PE) Connection
32
Mains Connector on Pump Bulkhead
33
Connect an Additional RF Earth (Ground) (Optional)
34
Connect to the Emergency Stop Circuit
34
Semi S2 Requirements
34
RF Earth Connection
34
Connect and Set up the Cooling Water
35
Accessories
35
Commission the System
35
Nitrogen Flow Meter
36
Install Additional Safety Equipment
37
Operation
39
Start-Up
39
Front Panel Control Operation
40
PDT Operation
40
Microtim Operation
40
Status Indicators
40
Manual Shut-Down
41
Shut-Down Modes
41
Front Panel Control Operation
41
PDT Operation
41
Microtim Operation
41
Automatic Shut-Down
42
Unplanned Shut down and Alarms
42
Emergency Stop
43
Restart the Pump after an Emergency Stop or Automatic Shut-Down
43
Advanced Control and Monitoring
43
Maintenance
45
Safety and Maintenance Frequency
45
Relocate the System for Maintenance
46
Draining the Cooling Water
47
General Maintenance
48
Inspect the Connections, Pipelines, Cables and Fittings
48
Gas Module Configuration
48
Transportation, Storage and Disposal
49
Transportation
49
Storage
49
Disposal
49
Service, Spares and Accessories
51
Introduction
51
Service
51
Accessories
52
Disconnect Box
52
Accessory Modules
52
Pump Display Terminal (PDT)
52
PDT Holster
52
Pump Display Terminal
52
PDT Extension Cable
53
Water Flow Control Valve (2 Lpm) & Monitor Assembly
53
Earth Leakage Circuit Breaker
53
Seismic Restraint Brackets
53
Photohelic Gauge Chimney
53
Nitrogen Flow Switch Assembly
54
Interface Modules
54
Appendix A1 Pump Display Terminal
57
A1.1 Leds
57
A1.2 Pump Start / Stop and Control
57
A1.3 Warning / Alarm Display and Acknowledgement
58
Menus
58
A1.4.1 Normal Menu
58
Normal Menu
58
A1.4.2 Status Menu
59
A1.4.3 SETUP Menu
59
Status Menu
59
SETUP Menu
59
A1.4.4 COMMANDS Menu
60
A1.4.5 INV FAULT HIST (Display Inverter Fault History) Menu
60
A1.4.6 SOFTWARE VERSION Display Menu
60
COMMANDS Menu
60
INV FAULT HIST (Display Inverter Fault History) Menu
60
A1.4.7 FIT ACCESSORY Menu
61
A1.4.8 IP Configuration Menu
61
FIT ACCESSORY Menu
61
IP Configuration Menu
61
A1.4.9 Display Attributes Menu
62
Display Attributes Menu
62
SELECT LINE (Normal Display Selection Menu)
62
UNITS (Units to Display)
62
Appendix A2 Troubleshooting
63
A2.1 Warnings
63
A2.1.1 LED Warning Indicators
63
A2.1.2 PDT Warnings
63
A13 Warnings
63
A2.2 Alarms
65
A2.2.1 LED Alarm Indicators
65
A2.2.2 PDT Alarms
65
A14 Alarms
65
A2.3 Inverter Warnings and Alarms
67
A15 Hexadecimal to Digital Conversion
67
A16 Inverter Alarm Codes
68
A17 Inverter Warnings Codes
68
A2.4 Other Problems
70
A2.4.1 Pump Controller Communications
70
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Edwards iXL600 and is the answer not in the manual?
Ask a question
Edwards iXL600 Specifications
General
Brand
Edwards
Model
iXL600
Category
Water Pump
Language
English
Related product manuals
Edwards iXL120
58 pages
Edwards iXL120N
60 pages
Edwards iXL500Q
88 pages
Edwards iXL250Q
88 pages
Edwards iXL750R
88 pages
Edwards iXL1000
70 pages
Edwards STP-iXL455
147 pages
Edwards iXH3030
88 pages
Edwards iXH3030T
88 pages
Edwards iXH6045H
88 pages
Edwards iXM Series
104 pages
Edwards STP-iXA3306C
181 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
