Home
Edwards
Water Pump
iXM Series
Edwards iXM Series User Manual
4
of 1
of 1 rating
104 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Figure 13
Coding pin
conguraon
Figure 14
Mains connector on pump bulkhead
Pin
idencaon
Pin A1
Phase 1
Pin A2
Phase 2
Pin B1
Phase 3
Pin B2
Not connected
Pin PE
Prot
ecve
earth
10/2020 - ©Edw
ards Limit
ed
Pag
e 41
M56635880_D
M56635880_D -
Inst
allaon
43
45
Table of Contents
Default Chapter
7
Table of Contents
7
1 Safety and Compliance
11
Definition of Warnings and Cautions
11
Safety Symbols
12
2 General Description
13
Overview
13
Figure 1 Front View of System
13
Applications
14
Figure 2 Controls/Connectors on the Rear of the System
14
Advanced Control and Monitoring
15
Green Mode
15
Figure 3 Applications
15
3 Technical Data
16
General Technical Data
16
Operating and Storage Conditions
16
Manufacturing Materials
17
Loading Data
18
Figure 4 Centre of Gravity and Levelling Foot Loads Ixm200
18
Figure 5 Centre of Gravity and Levelling Foot Loads Ixm600 and Ixm1200
19
Figure 6 Centre of Gravity and Levelling Foot Loads Ixm3000
20
Nitrogen Purge Data
21
Electrical Data
21
Cooling Water Data
24
Heater Data
25
Tracer Gas Analysis
26
4 Installation
28
Installation Safety
28
Unpack and Inspect
29
Position the System
30
Install the System
32
Figure 7 Reduce the Effective System Footprint
33
Lubrication
34
Connect the System
34
Connect to the Vacuum and Exhaust System
34
Figure 8 Reduce the Effective System Footprint Ixm3000
34
Connect the Pump Inlet
36
Figure 9 Connect the Pump Inlet (Ixm200 and Ixm3000)
36
Connect the Pump Exhaust
37
Connect to the Factory Extraction System (Optional)
37
Figure 10 Connect the Pump Inlet (Ixm600 and Ixm1200)
37
Connect the Nitrogen Supply
38
Connect to the Electrical Supply
39
Figure 11 Mains Input Supply Connector
43
Figure 12 Method for Connecting Phase Wires
43
Figure 13 Coding Pin Configuration
44
Figure 14 Mains Connector on Pump Bulkhead
44
Figure 15: Mains Input Supply Connector - Han® K 4/4
45
Figure 16 Protective Earth (PE) Connection
46
Connect an Additional RF Earth (Ground) (Optional)
47
Figure 17 Electrical Connector Locking Mechanism (Ixm200, Ixm600 and Ixm1200)
47
Figure 18 Electrical Connector Locking Mechanism
47
Connect to the Emergency Stop Circuit
48
Connect the Cooling Water Supply
48
Connect the Accessories
50
Install Additional Safety Equipment
51
5 Commission
52
Commission the System
52
Leak Test the System
53
Configure the System through a PDT
53
Pump Display Terminal
53
Figure 19 Pump Display Terminal
53
6 Operation
62
Start-Up
62
Start up through a Microtim
63
Start up through a PDT
63
Start up through the Front Panel Control
64
Restart the System after a Controlled Stop or Alarm Condition
64
Figure 20 Front Panel Controls
64
Restart the Pump after a Controlled Stop or Automatic Shut down
65
Shut down
65
Shut down Modes
66
Shut down through a Microtim
66
Shut down through a PDT
66
Shut down through the Front Panel Control
66
Controlled Stop
66
Gas Module Configuration
67
IXM Varimode Gas Module Adjustment Procedure
67
System Operating Temperature Configuration
68
7 Maintenance
69
Inspect the Connections, Pipelines, Cables and Fittings
70
8 Fault Finding
71
Warnings
71
LED Warning Indicators
71
PDT Warnings
71
Alarms
79
LED Alarm Indicators
79
PDT Alarms
79
Alarm Conditions
82
Unplanned Shut down and Alarms
83
Events
84
PDT Events
84
Inverter Warnings and Alarms
86
9 Decommissioning
88
Decommissioning Safety
88
Relocate the System for Decommissioning
89
Drain the Cooling Water for Decommissioning
90
Transportation
91
10 Storage
92
11 Disposal
93
12 Service
94
Return the Equipment or Components for Service
94
13 Accessories
96
Disconnect Box
96
Accessory Modules
96
Pump Display Terminal (PDT)
96
PDT Holster
97
PDT Extension Cable
97
Seismic Restraint Brackets
97
Nitrogen Flow Switch Assembly
97
Interface Modules
98
Microtim
98
EMS Modules
98
Igateway Modules
98
Exhaust Check Valve
99
Exhaust Extraction Cover Kit
99
Constant Flow Water Valves
99
Water Flow Monitor Assembly
100
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Edwards iXM Series and is the answer not in the manual?
Ask a question
Edwards iXM Series Specifications
General
Brand
Edwards
Model
iXM Series
Category
Water Pump
Language
English
Related product manuals
Edwards iXL120
58 pages
Edwards iXL600
70 pages
Edwards iXL500Q
88 pages
Edwards iXL750R
88 pages
Edwards iXH3050H
88 pages
Edwards iXH6045H
88 pages
Edwards iXH1820T
88 pages
Edwards iXH3045H
88 pages
Edwards iXH3030T
88 pages
Edwards iXH1220HT
88 pages
Edwards iXH4550HT
88 pages
Edwards iXH1210HT
88 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
