15.2.13 Inhalt/Contens Seite/Page 5
Inhalt / Contens
5.7 Installation of the water cooled exhaust system ......................................................... 65
5.7.1 Installation of the standard exhaust system ...................................................................... 65
5.8 .Installation of the waterlock ......................................................................................... 67
5.8.1 Possible cause for water in the exhaust hose ................................................................... 67
5.8.1.1 Possible cause: Exhaust hose .................................................................................................. 67
5.8.1.2 Possible cause: cooling water hose .......................................................................................... 67
5.8.2 Installation area of the waterlock ....................................................................................... 68
5.8.3 The volume of the waterlock ............................................................................................. 68
5.8.3.1 Ideal position of the waterlock....................................................................................................70
5.8.3.2 Example of the installation of the waterlock off-center and possible effects:.............................73
5.9 Exhaust / water separator .............................................................................................. 76
5.9.1 Installation exhaust water separator ................................................................................ . 78
5.10 Fuel system installation ................................................................................................. 78
5.10.1 Fischer Panda installation kit - Fuel system ...................................................................... 78
5.10.1.1 The following items need to be installed: .................................................................................. 80
5.10.2 Connection of the fuel lines at the tank ............................................................................. 83
5.10.3 Position of the pre-filter with water separator .................................................................. . 84
5.11 Generator DC system installation ................................................................................. 84
5.11.1 Connection of the starter battery block .............................................................................. 84
5.11.2 How to connect two 12V batteries to a 24V battery bank .................................................. 88
5.11.3 Connection of the remote control panel - See Panda iControl panel manual ................... 89
5.12 Generator AC system installation ................................................................................. 89
5.12.1 Installation PMGi inverter - See separate PMGi 15000 inverter manual ........................... 90
6 Generator operation instruction................................................................................. 91
6.1 Personal requirements .................................................................................................. 91
6.2 Hazard notes for the operation ..................................................................................... 91
6.3 General operating instruction ....................................................................................... 91
6.3.1 Operation at low temperatures .......................................................................................... 91
6.3.1.1 Pre-heating the diesel motor..................................................................................................... 92
6.3.1.2 Tips regarding starter battery.................................................................................................... 92
6.3.2 Light load operation and engine idle ................................................................................. 92
6.3.2.1 The soot of the generator is due to the fact that:....................................................................... 92
6.3.2.2 To prevent the soot of the generator following steps should be observed:............................... 92
6.3.3 Generator load for a longer period and overload .............................................................. 92
6.3.4 Protection conductor: ........................................................................................................ 93
6.3.5 Operating control system on the Fischer Panda generator ............................................... 93
6.4 Instructions for capacitors - not present at all models .............................................. 93
6.5 Checks before start - see remote control panel data sheet ....................................... 93
6.6 Starting the generator - see remote control panel data sheet ................................... 94
6.7 Stopping the generator - see remote control panel data sheet ................................. 94
6.8 ......................................................................................................................................... 94
7 Maintenance Instructions............................................................................................ 95
7.1 Personal requirements .................................................................................................. 95
7.2 Hazard notes for the maintenance ................................................................................ 95
7.3 Environmental protection .............................................................................................. 97
7.4 Maintenance Requirements ........................................................................................... 97
7.5 Maintenance interval ...................................................................................................... 97
To Next Page
Loading...
