Installation Instructions
Seite/Page 52 - Kaptitel/Chapter 5: Installation Instructions 15.2.13
• Only perform installation work using commercially available
tools and special tools. Incorrect or damaged tools can re-
sult injuries.
Warning!: Danger of fire
Oil and fuel vapours can ignite at contact with ignition sources.
Therefore:
• No open flames during work on the generator.
• Do not smoke.
• Remove oil and fuel residues from the generator and floor.
Danger!: Danger of poisoning
Contact with engine oil, antifreeze and fuel can result in dam-
age to health. Therefore:
• Avoid skin contact with engine oil, fuel and antifreeze.
• Remove oil and fuel splashes and antifreeze from the skin
immediately.
• Do not inhale oil and fuel vapours.
ATTENTION!: Danger to Life - High voltage
DANGER TO LIFE! - Improper handling can result in severe per-
sonal injury and death.
Electrical voltages above 48 volts (battery chargers greater than 36 volts)
are always dangerous to life. The rules of the respective regional authority
must be adhered to. Only an electrician may carry out installation of the elec-
trical connections for safety reasons.
Warning!: Hot surface/materialGenerator, oil and antifreeze can be hot during/after operation.
Risk of severe burns!
During operation an over pressure in the cooling system may be established.
Warning: Danger of chemical burnsBatteries contain corrosive acids and bases.
Improper handling can lead to heating of the batteries and bursts. Corrosive
acids and bases may leak. Under bad conditions it may lead to an explosion.
Consider the instructions of the battery manufacturer.
Instruction!: Personal protective equipment nec-
essary
During installation/maintenance personal protective equipment
is required to minimize the health hazards:
• Protective clothing
• Safety boots
• Protective gloves
• Ear defender
• Safety glasses
To Next Page