Harman P35I - Service & Maintenance; A. Shut-down Procedure; B. Quick Reference Maintenance Chart

29
Pellets or Corn/Pellet Mixture Only
P35i Fireplace Insert
Save These Instructions 3-90-775R15_04/13
10
Service & Maintenance
A. Shut-down Procedure
Thebestwaytoshutdowntheapplianceistosimply
let it run out of fuel, and shut down naturally as the
temperaturecools.Thismethodishighlyrecommended
fortheendofseasonshut-down.
To shut-down otherwise, turn the mode selector to
"OFF'verifybyensuringthattheStatuslightgoesout.
Theshut-downprotocolofthecircuitboardwillsafely
allowtheretogoout.Allmotorswillstopwhencool,
andonlythePOWERlightwillremainlit.Itisnowsafe
toun-plugtheelectricalsupply.

Proper Shut-down procedure must be followed.
• Smokespillagemayoccurifshut-downisnot
complete
• Riskofshockifapplianceisnotdisconnected
fromthesupplypowerpriortoservicing.
Cleaning or Inspection Frequency Daily Weekly Monthly Yearly
Areabeneathburnpotgrate/
Igniter Aftereachtonoffuelburned OR X
Ashremoval Dependingonfuelquality OR X X
Burnpotgratesurface Dependingonfuelquality OR X
Combustionblower/paddlefan Aftereachtonoffuelburned OR X
Distributionblower
Morefrequentlydependingon
surroundings OR X
Doorlatchinspection Priortoheatingseason OR X
Feederbody/Finescollection
area Dependingonfuelquality OR X
Firebox/thoroughcleaning Aftereachtonoffuelburned OR
 X
Glass
Whenviewofrebecomes
obstructed OR X
Heatexchanger Aftereachtonoffuelburned OR X
Hopper Wheneveraddingfuel OR X
Ventingsystem
Morefrequentlydependingon
fuelqualityandquantity OR X
Soot- Formation and Need For Removal-When
woodisburned,theproductsofcombustioncombine
withmoisturetoformasootresiduewhichaccumulates
on the ue lining. When ignited, this soot makes an
extremely hotre. Theentire venting system should
beinspectedat leastonceevery twomonthsduring
the heating season to determine if a soot buildup
has occurred. If soot has accumulated, it should be
removedtoreducetheriskofachimneyre.
If you experience a chimney re;Turnthecontrolto
"Off".Keepappliancedoorsandhopperlidclosedand
latched.Notifytheredepartment.Donotoperatethe
applianceuntilthechimneyandconnectorhavebeen
inspectedandapprovedbyachimneyprofessional.
B. Quick Reference Maintenance Chart

NOTICE: For recommendation purposes only -  More frequent cleaning is necessary if heavy buildup is
encounteredatthe recommendedintervals, or ifyou seesoot coming fromthe vent.  
