Jackson TempStar Series Installation, Operation & Service Manual

PARTSPARTS
43
MOTORS — WASH HEATERS — RINSE HEATERS
The models covered in this manual come supplied with various wash motor assemblies (a wash motor assembly includes
the wash motor and the pump end), depending on the characteristics of the machine. To ensure that the correct wash
motor assembly is ordered for the model being serviced, refer to the following table:
MODEL VOLTS Hz PHASE
WASH MOTOR
ASSEMBLY
Tempstar HH 415 50 3 06105-002-45-07
Tempstar HH, HH NB, HH S, HH LT 208 60 1 06105-002-01-29
Tempstar HH, HH NB, HH S, HH LT 230 60 1 06105-002-01-29
Tempstar HH, HH NB, HH S, HH LT 208 60 3 06105-002-01-29
Tempstar HH, HH NB, HH S, HH LT 230 60 3 06105-002-01-29
Tempstar HH, HH NB, HH S, HH LT 460 60 3 06105-002-09-30
NOTE: When servicing a wash motor please refer to the wiring schematic found on the motor to ensure that it is wired
correctly. Different manufacturers use different wire color codes and your new motor may not connect using the same
wires. Always refer to the diagrams on the motor you are installing. If the schematics have been removed from the motor
you are installing, contact Jackson technical support immediately.
The Tempstar models covered in this manual come supplied with various heaters, depending on the characteristics of the
machine. To ensure that the correct heater is ordered for the model being serviced, refer to the following table:
MODEL V Hz PH
WASH HEATER
ASSEMBLY
40°F RISE
RINSE HEATER
(12KW)
70°F RISE
RINSE HEATER
(14KW)
Tempstar HH 415 50 3 04540-002-43-09 04540-002-43-10 N/A
Tempstar HH 208 60 1 04540-121-47-39 04540-121-47-40 04540-121-63-38
Tempstar HH 230 60 1 04540-121-47-39 04540-121-47-40 04540-121-63-38
Tempstar HH 208 60 3 04540-121-47-39 04540-121-47-40 04540-121-63-38
Tempstar HH 230 60 3 04540-121-47-39 04540-121-47-40 04540-121-63-38
Tempstar HH 460 60 3 04540-121-65-99 04540-100-01-15 04540-121-63-39
Tempstar HH NB, HH LT 208 60 1 04540-121-47-39
Tempstar HH NB, HH LT 230 60 1 04540-121-47-39
Tempstar HH NB, HH LT 208 60 3 04540-121-47-39
Tempstar HH NB, HH LT 230 60 3 04540-121-47-39
Tempstar HH NB, HH LT 460 60 3 04540-121-65-99
Tempstar HH S 208 60 1 04540-121-47-39
Tempstar HH S 230 60 1 04540-121-47-39
Tempstar HH S 208 60 3 04540-121-47-39
Tempstar HH S 230 60 3 04540-121-47-39
Tempstar HH S 460 60 3 04540-121-65-99

Jackson TempStar Series Specifications

General

Model	TempStar Series
Voltage	208-240V
Number of Wash Cycles	1
Color	Stainless Steel
Category	Dishwasher
Voltage Options	208V, 240V
Capacity	60-80 racks per hour
Water Consumption per Cycle	0.5-1.0 gallons
Water Consumption per Rack	0.84 gallons