SERVICE SCHEDULE 9
37
after every race
Every 40 operating hours
Every 20 operating hours
Every 10 operating hours
After 1 operating hour
Check that the throttle cables are undamaged, routed without sharp bends, and set cor-
rectly.
○ ● ● ● ●
Clean the air filter and air filter box. ( p. 64) ● ● ● ●
Change the glass fiber yarn filling in the main silencer. ( p. 66) ● ●
Service the fork. ●
Perform the shock absorber service. ●
Check the tightness of the easily accessible, safety-relevant screws and nuts. ○ ● ● ● ●
Check the idle speed. ○ ● ● ● ●
Final check: Check the vehicle for operating safety and take a test ride. ○ ● ● ● ●
Make a service entry in the KTM Dealer.net. ○ ● ● ● ●
○ One-time interval
● Periodic interval
9.3 Recommended work
after every race
Every 40 operating hours
After 20 operating hours / Every 20 operating hours
After 10 operating hours / Every 10 operating hours
every 48 months
every 12 months
Change the front brake fluid. ● ●
Change the rear brake fluid. ● ●
Change the hydraulic clutch fluid. ( p. 78) ● ●
Lubricate the steering head bearing. ( p. 56) ● ●
Service the fork. ○
Perform the shock absorber service. ○
Check the starter drive. (125 XC US) ● ●
Check/adjust the carburetor components. ● ● ●
Change the needle jet. ● ● ●
Change the coolant. ( p. 107) ●
Perform minor engine service. (Check the inlet membrane. Check the clutch. Under
difficult operating conditions: Change the piston and check the cylinder and Z
dimension.)
● ● ● ●
Perform the intermediate engine service. (Change the piston and check the cylin-
der and Z dimension. Check the exhaust control for functioning and smooth opera-
tion.)
● ●
Perform major engine service including removing and installing the engine. (Change
the connecting rod, conrod bearing, and crank pin. Check the transmission and shift
mechanism. Change all engine bearings.)
●
○ One-time interval
● Periodic interval
To Next Page
Loading...
