Long 2360 User Manual

TROUBLE SHOOTING
The following suggestions are listed for your assis-
tance. You can make simple adjustments on your
tractor that will improve its' operation and save you time
and expense of having a service technician look
at your
problem.
HAAD TO START
If any trouble is experienced, make sure of the cause
before attempting to make any repairs
or adjustments.
Always make one adjustment at a time, so that it the
adjustment made dose not improve the problem, then
return to its original seUing before proceeding to the
next adjustment. '
Cold Air Temperature
............................... Use thermo-start aid, see Cold Start Procedure
No Fuel
.......................................... Refill the fuel tank and bleed the fuel system
Air Trapped in Fuel System
.......................... Bleed the fuel system
Flooded Engine
.................................... Crank the engine with the fuel shut off knob pulled out
until the excess fuel is
out of the cylinders, then follow
normal starting procedures
Incorrect Timing
................................... Have your LONG dealer reset the timing
Loss of Compression ............................... Check the head gasket, see your LONG dealer
Dirty Nozzles
...................................... Have your LONG dealer check and clean the nozzles
Defective Battery
................................... Check battery
Valve Clearance Incorrect
........................... Have your LONG dealer check and correct valve
clearance
Fuel Transfer Pump Faulty
........................... See your LONG dealer
Fuel Injection Pump Faulty .
.. ........................ See your LONG dealer •
Fuel Injection Pump Out of Time
...................... See your LONG dealer
ENGINE OVERHEATING
Low Coolant Level in Cooling System . .
............ .... Fill radiator to proper level
Radiator Clogged
.................................. Clean cooling system
Fan Belt Slipping
................................... Tighten fan belt
Collapsed Radiator Hose
............................ Replace hose
Radiator Cores Clogged
.... ....... ................. . Remove all dirt and chaff from radiator grill; clean with
compressed air
or water •
Thermostat Not Functioning
or Stuck .... ... .......... .. Install new thermostat of correct range
Engine Overloaded
... ...... .............. . ......... Reduce engine load or use a lower gear
Diluted Lubricating Oil
............................... See your LONG dealer
Water Pump Impeller Vans Broken
..................... Replace the water pump
LOSS OF POWER
Insufficient Fuel
.................................... Refill the fuel tank and bleed the fuel system
Air in Fuel System
.................................. Bleed the fuel system
Obstruction in Fuel Line
.......................... ... Clean the fuel system
Transfer Pump Defective
............................ Replace the transfer pump
Late Injection Timing
................................ See your LONG dealer
Loss of Compression
............................... See your LONG dealer
Clogged Air Cleaner or Restricted Air Flow
.............. Clean the air cleaner element
Sticking Valves ... .. .. . .. .......................... See your LONG dealer
Valve Clearance Incorrect
... . ................... ... .. See your LONG dealer
Faulty Nozzles
.. . .... ............. ... .. . ... . ..... .. Clean or replace nozzles
High Idle RPM's Too Slow
.... ... ..... ... .. .. ........ See your LONG dealer
46

Long 2360 Specifications

General

Engine Power	36 hp
Engine Type	Diesel
PTO Speed	540 rpm
Type	Tractor
Hydraulic Remotes	2