Page 6-18 2014 MasterCraft Owners Manual • Care and Maintenance
C A R E A N D M A I N T E N A N C E
suretheignitionkeyandallaccessoriesare
in the OFF position. Also remember to re-
attach the cables in the proper order, with
the positive cable connected to the positive
[+] post and the negative cable connected
to the negative [-] post.
When charging, batteries generate small
amounts of dangerous hydrogen gas. This
gas is highly explosive. Keep all sparks,
flames and smoking well away from the
area. Failure to follow instructions when
charging a battery may cause an electrical
charge or even an explosion of the battery,
which could result in death or serious injury.
MasterCraft recommends the use of a
spiral-celltypebattery,suchastheOptima
brand. These batteries exceed other batter-
ies in holding and extending a charge.
Inspect the Throttle and Shift Cables
for Kinks, Wear and Interference
Some engine parts become very hot during
operation. This inspection must be complet-
ed while the engine is cool to prevent burns
to your skin. Perform this task before start-
ing the boat.
Step 1: Ensure the engine is OFF and the
enginesafetystartingswitchdiscon-
nected. Be certain that the throttle/
shift control lever is in neutral.
Step 2: Open the engine compartment
and locate the throttle and shift
cables. Follow each cable back
undertheoorboardsandfeelfor
any kinks and wear on the outer
jacket.Anysignofcabledamage
iscauseforreplacement.Seeyour
authorized MasterCraft dealer’s
service department if you notice
anycabledamage.
Inspect the Fuel System for Leaks
This function should be performed prior
to starting the engine; and then again after
about three (3)-to-ve (5) minutes to deter-
mine whether any leaks are apparent.
Step 1: First ensure the engine is OFF and
theenginesafetystartingswitchis
disconnected. Be certain that the
throttle/shift control lever is in
neutral. The engine must be cool.
Gasoline is highly flammable and its vapors
may ignite, resulting in fire or explosion. Be
sure to keep all sparks and flames away
from the area while inspecting the boat’s
fuel system.
Step 2: Open the engine compartment
and visually check as much of
thefuelsystemfromthe tankto
the engine as you can see. On
some models this is will be a lim-
itedarea.Iftheodorofgasoline
To Next Page
Loading...
Need help?
General
